UFC 3-430-09 CHANGE 1-2009 EXTERIOR MECHANICAL UTILITY DISTRIBUTION.pdf

1、 UFC 3-430-09 16 January 2004with Change 1, 25 March 2009 UNIFIED FACILITIES CRITERIA (UFC) EXTERIOR MECHANICAL UTILITY DISTRIBUTIONAPPROVED FOR PUBLIC RELEASE; DISTRIBUTION UNLIMITED Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-UFC 3-430-09 16 Ja

2、nuary 2004with Change 1, 25 March 2009 UNIFIED FACILITIES CRITERIA (UFC) EXTERIOR MECHANICAL UTILITY DISTRIBUTIONAny copyrighted material included in this UFC is identified at its point of use. Use of the copyrighted material apart from this UFC must have the permission of the copyright holder. U.S.

3、 ARMY CORPS OF ENGINEERS NAVAL FACILITIES ENGINEERING COMMAND (Preparing Activity) AIR FORCE CIVIL ENGINEERING SUPPORT AGENCY Record of Changes (changes indicated by 1 . /1/ ) Change No. Date Location 1 -This document replaces UFC 3-430-09N and UFC 3-430-05FA. Provided by IHSNot for ResaleNo reprodu

4、ction or networking permitted without license from IHS-,-,-8) all other DoD agencies may use this document unless explicitly directed otherwise. 1-2.1 GENERAL BUILDING REQUIREMENTS. All DoD facilities must comply with UFC 1-200-01, Design: General Building Requirements. If any conflict occurs betwee

5、n this UFC and UFC 1-200-01, the requirements of UFC 1-200-01 take precedence. 1-2.2 SAFETY. All DoD facilities must comply with DODINST 6055.1 and applicable Occupational Safety and Health Administration (OSHA) safety and health standards. NOTE: All NAVY projects, must comply with OPNAVINST 5100.23

6、 (series), Navy Occupational Safety and Health Program Manual. The most recent publication in this series can be accessed at the NAVFAC Safety web site: www.navfac.navy.mil/safety/pub.htm. If any conflict occurs between this UFC and OPNAVINST 5100.23, the requirements of OPNAVINST 5100.23 take prece

7、dence. 1-2.3 FIRE PROTECTION. All DoD facilities must comply with UFC 3-600-01, Design: Fire Protection Engineering for Facilities. If any conflict occurs between this UFC and UFC 3-600-01, the requirements of UFC 3-600-01 take precedence. 1-2.4 ANTITERRORISM/FORCE PROTECTION. All DoD facilities mus

8、t comply with UFC 4-010-01, Design: DoD Minimum Antiterrorism Standards for Buildings. If any conflict occurs between this UFC and UFC 4-010-01, the requirements of UFC 4-010-01 take precedence. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-UFC 3-4

9、30-09N 16 January 2004A-1 APPENDIX A MIL-HDBK 1003/8A EXTERIOR DISTRIBUTION OF STEAM, HIGH PRESSURE WATER, CHILLED WATER, NATURAL GAS, AND COMPRESSED AIR Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,- INCH-POUND MIL-HDBK-1003/8A 15 AUGUST 1990SUPER

10、SEDINGMIL-HDBK-1003/830 SEPTEMBER 1987MILITARY HANDBOOKEXTERIOR DISTRIBUTION OF STEAM,HIGH TEMPERATURE WATER, CHILLED WATER,NATURAL GAS, AND COMPRESSED AIRNO DELIVERABLE DATA REQUIRED BY THIS DOCUMENT AREA FACRDISTRIBUTION STATEMENT A. APPROVED FOR PUBLIC RELEASE: DISTRIBUTION ISUNLIMITEDProvided by

11、 IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-1003/8AABSTRACTPresented here is basic yet comprehensive design guidance and technical datafor exterior distribution piping systems. Services supported by these systemsinclude: steam supply, high-temperat

12、ure water, chilled water, cooling orcondensing water, natural gas, and compressed air to various buildings andother facilities. This handbook also contains data covering return systemsfor condensate, water, and other spent services. Additional design dataincludes information on loads and fluid condi

13、tions, fluid characteristics, anddistribution site locations. Factors governing tests for field permeability,soil resistivity, soil stability, and water conditions, information ondistribution pipe sizing, valves and supports, distribution methods, andpiping specifications and codes are provided. Mat

14、erial included also coversownership, operations, and maintenance cost variables associated withpermanent or temporary sites.iiProvided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-1003/8AChange 2, 30 December 1991FOREWORDThis military handbook has

15、 been developed from an extensive evaluation ofshore establishment facilities, surveys of new materials availability andconstruction methods, selections from the best design practices of the NavalFacilities Engineering Command (NAVFACENGCOM), other government agencies andthe private sector. MIL-HDBK

16、-1003/8A uses and references design datastandards established and validated by national professional societies,associations, and technical institutes. Deviations from these criteria, inplanning, engineering, design and construction of naval shore facilities,cannot be made without prior approval of N

17、AVFACENGCOM HQ Code 04.Design methods and practices cannot remain static any more than the functionsthey serve or the technologies used. Accordingly, recommendations forimprovement are encouraged and should be furnished on the DD Form 1426provided inside the back cover to Commander, Western Division

18、, NavalFacilities Engineering Command, Code 406, Building 203, San Bruno, CA 94066,telephone (415) 244-3331.THIS HANDBOOK SHALL NOT BE USED AS A REFERENCE DOCUMENT FOR PROCUREMENT OFFACILITIES CONSTRUCTION. IT IS TO BE USED IN THE PURCHASE OF FACILITIESENGINEERING STUDIES AND DESIGN (FINAL PLANS, SP

19、ECIFICATIONS, AND COSTESTIMATES). DO NOT REFERENCE IT IN MILITARY OR FEDERAL SPECIFICATIONS OROTHER PROCUREMENT DOCUMENTS.iiiProvided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,- MIL-HDBK-1003/8A NOTICE OF NOTICE 1 CHANGE 30 AUGUST 1991MILITARY HANDBOOKEX

20、TERIOR DISTRIBUTION OF STEAM, HIGH TEMPERATURE WATERCHILLED WATER, NATURAL GAS, AND COMPRESSED AIRTO ALL HOLDERS OF MIL-HDBK-1003/8A:1. THE FOLLOWING PAGES OF MIL-HDBK-1003/8A HAVE BEEN REVISED ANDSUPERSEDE THE PAGES LISTED:NEW PAGE DATE SUPERSEDED PAGE DATE63 30 August 1991 63 REPRINTED WITHOUT CHA

21、NGE64 30 August 1991 64 30 August 19912. RETAIN THIS NOTICE AND INSERT BEFORE TABLE OF CONTENTS.3. Holders of MIL-HDBK-1003/8A will verify that all changes indicatedabove have been made. This notice page will be retained as a check sheet. This issuance, together with appended pages, is a separate pu

22、blication. Each notice is to be retained by stocking points until the militaryhandbook is completely revised or canceled.CUSTODIAN: PREPARING ACTIVITY:NAVY-YD NAVY-YDPROJECT NO.FACR-1061AMSC N/ADISTRIBUTION STATEMENT A. APPROVED FOR PUBLIC RELEASE: DISTRIBUTIONUNLIMITEDivProvided by IHSNot for Resal

23、eNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-1003/8ANOTICE 215 November 1991MILITARY HANDBOOKEXTERIOR DISTRIBUTION OF STEAM, HIGH TEMPERATURE HOTWATER, CHILLED WATER, NATURAL GAS AND COMPRESSED AIRTO ALL HOLDERS OF MIL-HDBK-1003/8A1. THE FOLLOWING PAGES OF MIL-HDBK-

24、1003/8A HAVE BEEN REVISED AND SUPERSEDETHE PAGES LISTED:NEW PAGE DATE SUPERSEDED PAGE DATE41 15 November 1991 41 15 August 199042 15 November 1991 42 15 August 19902. RETAIN THIS NOTICE AND INSERT BEFORE TABLE OF CONTENTS.3. Holders of MIL-HDBK-1003/8A will verify that all changes indicated abovehav

25、e been made. This notice page will be retained as a check sheet. Thisissuance, together with appended pages, is a separate publication. Eachnotice is to be retained by stocking points until the Military Handbook iscompletely revised or cancelled.CUSTODIANS: PREPARING ACTIVITY:NAVY-YD NAVY-YDPROJECT

26、NO. FACR-1063DISTRIBUTION STATEMENT A. Approved for public release; distribution isunlimited.vProvided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-1003/8AChange 2, 30 December 1991MECHANICAL ENGINEERING CRITERIA MANUALSCriteria PreparingManual Ti

27、tle ActivityDM-3.01 Plumbing Systems WESTDIVMIL-HDBK-1003/2 Incinerators WESTDIVDM-3.03 Heating, Ventilating, Air Conditioning, WESTDIVand Dehumidifying SystemsDM-3.4 Refrigeration Systems for Cold Storage WESTDIVDM-3.5 Compressed Air and Vacuum Systems WESTDIVMIL-HDBK-1003/6 Central Heating Plants

28、NEESAMIL-HDBK-1003/7 Steam Power Plants - Fossil Fueled NEESAMIL-HDBK-1003/8A Exterior Distribution of Steam, High WESTDIVTemperature Water, Chilled Water,Natural Gas, and Compressed AirDM-3.09 Elevators, Escalators, Dumbwaiters, WESTDIVAccess Lifts, and Pneumatic TubeSystemsDM-3.10 Noise and Vibrat

29、ion Control for ARMYMechanical Equipment (Tri-ServiceTM-5-805-4, AFM 88-37)MIL-HDBK-1003/11 Diesel Electric Generating Plants WESTDIVMIL-HDBK-1003/12 Boiler Controls NEESAMIL-HDBK-1003/13 Solar Heating of Buildings and NCELDomestic Hot WaterDM-3.14 Power Plant Acoustics (Tri-Service ARMYTM-5-805-9,

30、AFM 88-20)MIL-HDBK-1003/17 Industrial Ventilation Systems NEESAMIL-HDBK-1003/19 Design Procedures for Passive NCELSolar BuildingsviProvided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-HDBK-1003/8ANOTICE 230 December 1991MILITARY HANDBOOKEXTERIOR DISTR

31、IBUTION OF STEAM, HIGH TEMPERATURE HOTWATER, CHILLED WATER, NATURAL GAS, AND COMPRESSED AIRTO ALL HOLDERS OF MIL-HDBK-1003/8A1. THE FOLLOWING PAGES OF MIL-HDBK-1003/8A HAVE BEEN REVISED AND SUPERSEDE THEPAGES LISTED:NEW PAGE DATE SUPERSEDED PAGE DATEiii 30 December 1991 iii 15 August 1991iv 30 Decem

32、ber 1991 iv 15 August 1990v 30 December 1991 v 15 August 1991vi 30 December 1991 vi 15 August 1990vii 30 December 1991 vii 15 August 1990viii 30 December 1991 viii 15 August 19901 30 December 1991 1 Reprinted w/o Change2 30 December 1991 2 15 August 19903 30 December 1991 3 15 August 19904 30 Decemb

33、er 1991 4 Reprinted w/o Change9 30 December 1991 9 15 August 199010 30 December 1991 10 15 August 199013 30 December 1991 13 15 August 199014 30 December 1991 14 Reprinted w/o Change37 30 December 1991 37 15 August 199038 30 December 1991 38 15 August 199041 30 December 1991 41 15 August 199042 30 D

34、ecember 1991 42 15 August 199042a 30 December 1991 New Page45 30 December 1991 45 15 August 199046 30 December 1991 46 Reprinted w/o Change47 30 December 1991 47 15 August 199048 30 December 1991 48 15 August 199063 30 December 1991 63 Reprinted w/o Change64 30 December 1991 64 30 August 199181 30 D

35、ecember 1991 81 Reprinted w/o Change82 30 December 1991 82 15 August 199083 30 December 1991 82 15 August 199084 30 December 1991 82 15 August 199085 30 December 1991 82 15 August 19902. RETAIN THIS NOTICE AND INSERT BEFORE TABLE OF CONTENTS.viiProvided by IHSNot for ResaleNo reproduction or network

36、ing permitted without license from IHS-,-,-3. Holders of MIL-HDBK-1003/8A will verify that all changes indicated above havebeen made. This notice page will be retained as a check sheet. This issuance,together with appended pages, is a separate publication. Each notice is to beretained by stocking po

37、ints until the Military Handbook is completely revised orcancelled.CUSTODIANS: PREPARING ACTIVITY:NAVY-YD NAVY-YDPROJECT NO.FACR-1063DISTRIBUTION STATEMENT A. Approved for public release; distribution is unlimited.viiiProvided by IHSNot for ResaleNo reproduction or networking permitted without licen

38、se from IHS-,-,-MIL-HDBK-1003/8AChange 2, 30 December 1991EXTERIOR DISTRIBUTION OF STEAM, HIGH TEMPERATURE WATER,CHILLED WATER, NATURAL GAS, AND COMPRESSED AIRCONTENTSPageSection 1 INTRODUCTION 1.1 Scope . . . . . . . . . . . . . . . . . . . . . . . . . 11.2 Cancellation. . . . . . . . . . . . . . .

39、 . . . . . . . 11.3 Related Criteria. . . . . . . . . . . . . . . . . . . . 1Section 2 PLANNING FACTORS 2.1 Types of Exterior Distribution Systems. . . . . . . . . 22.1.1 Steam and Condensate. . . . . . . . . . . . . . . . . . 22.1.2 Hot Water . . . . . . . . . . . . . . . . . . . . . . . 22.1.3 Com

40、pressed Air. . . . . . . . . . . . . . . . . . . . . 22.1.4 Chilled Water . . . . . . . . . . . . . . . . . . . . . 22.1.5 Cooling or Condensing Water . . . . . . . . . . . . . . 22.1.6 Natural Gas . . . . . . . . . . . . . . . . . . . . . . 22.2 Naval Facilities Guide Specifications (NFGS) Related

41、toDistribution Systems. . . . . . . . . . . . . . . . . 32.2.1 NFGS-02685, Exterior Buried Natural GasDistribution Systems. . . . . . . . . . . . . . . . . 32.2.2 NFGS-02693, Exterior Shallow Trench HeatDistribution System . . . . . . . . . . . . . . . . . 32.2.3 NFGS-02694, Exterior Underground Hea

42、t DistributionSystems . . . . . . . . . . . . . . . . . . . . . . . 32.2.4 NFGS-02695, Exterior Aboveground Steam DistributionSystem. . . . . . . . . . . . . . . . . . . . . . . . 32.2.5 NFGS-02696, Exterior Piping Insulation. . . . . . . . . 42.2.6 NFGS-02697, Exterior Buried Pumped CondensateRetur

43、n System . . . . . . . . . . . . . . . . . . . . 42.2.7 NFGS-02698, Exterior Buried Preinsulated WaterPiping. . . . . . . . . . . . . . . . . . . . . . . . 42.2.8 Exterior Compressed Air Piping System . . . . . . . . . 42.3 Loads and Distribution System Locations . . . . . . . . 42.3.1 Requirements

44、for Individual Facilities. . . . . . . . . 52.3.2 System Load Demand Factors. . . . . . . . . . . . . . . 52.3.3 Aboveground and Underground Systems . . . . . . . . . . 52.3.4 Distribution Routes . . . . . . . . . . . . . . . . . . 52.3.4.1 Aboveground Piping Routes . . . . . . . . . . . . . . . 52.3.4.2 Buried Piping Routes. . . . . . . . . . . . . . . . . . 82.3.5 Economic Studies. . . . . . . . . . . . . . . . . . . . 82.3.5.1 Annual Owning, Operating, and Maintenance Costs . . . . 82.3.5.2 Steam Versus High Temperature Water Distribution. . . . 82.3.5.3 High-Pressure (abo