ASTM D6860-2003 Proposed Standard Tables of Body Measurements for Boys Sizes 6 to 24 Husky《个子在6到24的男孩的身体测量建议标准表》.pdf

1、Designation: D 6860 03Proposed Standard Tables ofBody Measurements for Boys, Sizes 6 to 24 Husky1This proposed definitions standard has no status as an ASTM standard and is published on behalf of the sponsoring committee forinformation only for a maximum of two years. Comments are solicited and shou

2、ld be addressed to ASTM, 100 Barr Harbor Dr., WestConshohocken, PA 19428. When referencing this document, the word 9Proposal9 must precede the P designation.INTRODUCTIONThese tables were developed from body measurements used currently by apparel manufacturers andretail organizations. The measurement

3、s were derived originally from the 1970 Voluntary ProductStandard PS 36-70 by the U.S. Department of Commerce National Bureau of Standards.21. Scope1.1 These tables list body measurements of boys, sizes 6 to24 Husky. Although these are body measurements, they can beused as a baseline in designing ap

4、parel for boys and students inthis size range when considering such factors as fabric type,ease for body movement, styling, and fit.1.2 The husky body has a heavier build and higher bodyweight than other boys size ranges.1.3 The values stated in either acceptable SI units orinch-pound units shall be

5、 regarded separately as standard. Thevalues stated in each system may not be exact equivalents;therefore, each system must be used independently of the other,without combining values in any way.1.4 This standard does not purport to address all of thesafety concerns, if any, associated with its use.

6、It is theresponsibility of the user of this standard to establish appro-priate safety and health practices and determine the applica-bility of regulatory limitations prior to use.2. Referenced Documents2.1 ASTM Standards:D 123 Terminology Relating to Textile Materials3D 5219 Terminology Relating to

7、Body Dimensions forApparel Sizing42.2 ISO Standard:ISO 3635 Size Designation of Clothes, Definitions, andBody Measurement Procedures53. Terminology3.1 Definitions:3.1.1 For definitions relating to body dimensions, refer toTerminology D 5219.3.1.2 For definitions of other textile terms used in thisst

8、andard, refer to Terminology D 123.4. Significance and Use4.1 The use of the body measurement information in Tables1 and 2 will assist manufacturers in developing patterns andgarments that are consistent with the current anthropometriccharacteristics of the population of interest. This practiceshoul

9、d in turn reduce or minimize consumer confusion anddissatisfaction related to apparel sizing. (Also refer to ISO3635 Size Designation Procedures.)5. Apparatus5.1 Tape Measure, dimensionally stable and approximately15-mm (12-in.) wide and accurately graduated in mm (116-in.)increments.5.2 Plastic Gon

10、iometer, to measure the degree of shoulderslope.5.3 Scale, standard, calibrated body weight type.6. Procedure6.1 General:6.1.1 For all measurements, subject is to be standing erect,arms down, without shoes and with feet approximately 15-cm(6-in.) apart unless otherwise specified. For 6.2.8, 6.2.9, a

11、nd6.2.28 through 6.2.30, arm is to be bent at 1.57 rad (90), andthe hand placed on the hip.6.1.2 Take measurements over regular undergarments nor-mally worn.6.1.3 Take all measurements from the same side of the bodyfor consistency.6.1.4 Refer to Terminology D 5219 for the location of allpoints to be

12、 measured.1This test method is under the jurisdiction of ASTM Committee D13 on Textilesand is the direct responsibility of Subcommittee D13.55 on Body Measurement forApparel Sizing.Current edition approved Feb. 10, 2003. Published May 2003.2U.S. Department of Commerce, Voluntary Product Standard: Bo

13、dy Measure-ments for the Sizing of Boys Apparel, NIST Publication No. PS 36-70, Washington,DC.3Annual Book of ASTM Standards, Vol 07.01.4Annual Book of ASTM Standards, Vol 07.02.5Available from American National Standards Institute (ANSI), 25 W. 43rd St.,4th Floor, New York, NY 10036.1Copyright ASTM

14、 International, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959, United States.TABLE1HuskyBoysSizes6to24BodyMeasurements,SIUnitsSize6789101112131415161718192021222324Stature,cm116.8121.9127.0132.1137.2142.2147.3151.1154.9158.7162.6165.1167.6170.2172.7175.3177.8180.3182.9BodyWeig

15、ht,kg2527.730.433.136.739.943.146.750.854.959.062.164.968.070.873.977.180.784.4GirthMeasurementsinCentimetresChestGirth66.067.969.871.873.776.278.781.383.886.488.990.892.794.696.598.4100.3102.2104.1WaistGirth62.263.564.866.067.368.669.871.173.774.976.277.578.780.081.382.583.885.186.4HipGirth66.769.2

16、71.874.377.579.481.984.587.089.592.193.795.296.898.4100.0101.6103.2104.8NeckBaseGirth30.531.131.732.433.033.734.334.935.936.837.838.739.740.641.642.543.544.445.4ArmscyeGirth29.230.231.132.133.334.635.937.138.439.740.641.642.543.544.445.446.447.348.3Upper-ArmGirth19.019.720.321.021.622.222.923.524.42

17、5.426.427.327.928.629.229.830.531.131.7ElbowGirth20.321.021.622.222.923.824.825.726.727.327.928.629.229.830.531.131.732.433.0ThighGirth38.139.741.342.944.446.047.649.250.552.453.054.054.955.956.857.858.759.760.6KneeGirth26.427.328.329.230.231.132.133.034.034.635.235.936.537.137.838.439.139.740.3Calf

18、Girth24.825.726.727.628.629.530.531.432.433.334.334.935.636.236.837.538.138.739.4TotalVerticalTrunkLength110.5114.3118.1121.9125.7129.5133.3137.2141.0144.8148.6152.4154.9157.5160.0162.6165.1167.6170.2TotalCrotchLength52.454.356.258.160.061.963.865.767.669.571.473.374.675.977.278.479.781.082.2Vertica

19、lMeasurementsinCentimetresCervicaleHeight96.5101.3105.7110.4115.3120.0124.8128.3131.8135.9138.7141.0143.2145.7148.0150.5152.7155.3157.5HeadandNeckLength20.320.621.321.621.922.222.522.923.223.523.824.124.424.424.824.825.125.125.4CenterBackWaistLength26.427.328.329.230.231.132.133.034.034.935.936.837.

20、839.140.041.342.243.544.4CenterFrontWaistLength24.124.825.726.727.328.328.929.830.531.132.132.733.334.335.236.236.837.838.7ScyeDepth13.313.714.314.615.215.616.216.517.117.518.118.419.019.420.020.321.021.321.9WaistHeight71.174.978.782.586.490.294.096.599.1101.6104.1105.4106.7107.9109.2110.5111.8113.0

21、114.3WaisttoHipHeight14.915.215.615.916.516.817.517.818.418.719.419.720.320.621.321.622.222.523.2CrotchHeight49.853.056.259.462.565.768.970.872.774.676.577.578.479.480.381.382.283.284.1KneeHeight31.132.734.335.937.539.140.641.943.244.445.746.447.047.648.348.949.550.250.8AnkleHeight6.06.06.06.36.36.3

22、6.36.76.76.76.77.07.07.07.07.07.07.07.0WidthandLengthMeasurementsinCentimetresShoulderLength7.98.38.68.99.29.59.810.210.510.811.111.411.712.112.412.713.013.313.7BackWidth26.727.328.328.929.830.531.432.133.033.734.634.935.936.537.137.838.439.139.7FrontChestWidth22.523.524.125.125.726.727.328.328.929.

23、830.531.432.133.033.734.635.236.236.8ArmLength41.343.545.647.849.852.154.155.757.158.760.261.362.163.364.665.666.567.568.4ShoulderandArmLength49.251.854.156.759.161.664.065.967.669.571.372.773.875.477.078.379.580.882.1CervicaletoWrist54.657.159.762.264.867.369.871.873.775.677.578.780.081.683.284.585

24、.787.088.3ShoulderSlope(rad)0.40.40.40.40.40.40.40.40.40.40.40.40.40.40.40.40.40.40.4D6860032TABLE2HuskyBoysSizes6to24BodyMeasurements,InchPoundUnitsSize6789101112131415161718192021222324Stature,in.464850525456585912616212646566676869707172BodyWeight,lb55616773818895103112121130137143150156163170178

25、186GirthMeasurementsinInchesChestGirth26263427122814293031323334353534361237143838343912401441WaistGirth24122525122626122727122829291230301231311232321233331234HipGirth26142714281429143012311432143314341435143614367837123818383439384040584114NeckBaseGirth121214121212341313141312133414181412147815141

26、5581616381634171817121778ArmscyeGirth111211781214125813181358141814581518155816163816341718171217781814185819Upper-ArmGirth712734881481283499149581010381034111114111211341212141212ElbowGirth88148128349938934101810121034111114111211341212141212123413ThighGirth15155816141678171218181834193819782058207

27、8211421582222382234231823122378KneeGirth10381034111811121178121412581313381358137814181438145814781518153815581578CalfGirth934101810121078111411581212381234131813121334141414141214341515141512TotalVerticalTrunkLength43124546124849125152125455125758126061626364656667TotalCrotchLength20582138221822782

28、35824382518257826582738281828782938297830383078313831783238VerticalMeasurementsinInchesCervicaleHeight383978415843124538471449185012517853125458551256385738581459146018611862HeadandNeckLength8818838812858834878991891493891295895893493497897810CenterBackWaistLength103810341118111211781214125813133813

29、34141814121478153815341614165817181712CenterFrontWaistLength912934101810121034111811381134121214125812781318131213781414141214781514ScyeDepth51453855853466186386126346787187147127587788814838858WaistHeight2829123132123435123738394041411242421243431244441245WaisttoHipHeight578661861461265867877147387

30、587348818838812834878918CrotchHeight19582078221823382458257827182778285829383018301230783114315832323832343318KneeHeight121412781312141814341538161612171712181814181218341919141912193420AnkleHeight238238238212212212212258258258258234234234234234234234234WidthandLengthMeasurementsinInchesShoulderLeng

31、th31831433831235833437844184144384124584344785518514538BackWidth101210341118113811341212381258131314135813341418143814581478151815381558FrontChestWidth87891491297810181012103411181138113412123812581313141358137814141412ArmLength161417181715161919582012215162222122318231116241824716252571625131626316

32、26916261516ShoulderandArmLength193820382151622382328241425316262658273828285829291116305163013163151631131632516CervicaletoWrist211222122312241225122612271228142929343012313112321832343314333434143434ShoulderSlope(degrees)25252525252525252525252525252525252525D68600336.2 Body Measurements:6.2.1 Stat

33、ureMeasure the vertical distance taken from thecrown of the head to the floor with subject standing andwithout shoes.6.2.2 Body WeightMeasure on a calibrated scale take withthe subject in undergarments.6.2.3 Chest GirthMeasure the horizontal circumferencearound the body under the arms and across the

34、 bust apexincluding the lower portion of the shoulder blades.6.2.4 Waist GirthMeasure the minimum horizontal cir-cumference around the body at waist height.6.2.5 Hip GirthMeasure the maximum horizontal circum-ference around the body at hip height.6.2.6 Neck Base GirthMeasure the circumference of the

35、neck, over the cervicale at the back, and the top of the collarbone at the front.6.2.7 Armscye GirthMeasure the circumference from theshoulder joint through the front-break point, the armpit, theback-break point, and back to the starting point with the armdown.6.2.8 Upper-Arm GirthMeasure the maximu

36、m circumfer-ence of the arm midway between the elbow and shoulder joint.6.2.9 Elbow GirthMeasure the maximum circumferenceof the elbow over the outer prominence of the elbow bone.6.2.10 Thigh GirthMeasure the maximum horizontal cir-cumference of the upper leg close to the crotch.6.2.11 Knee GirthMea

37、sure the maximum horizontal cir-cumference of the knee over the knee cap with the leg straight.6.2.12 Calf GirthMeasure the maximum horizontal cir-cumference of the lower leg between the knee and the ankle.6.2.13 Total Vertical Trunk LengthMeasure the circumfer-ence from a point on the right shoulde

38、r midway between theneck base and shoulder joint, down the back, through thecrotch, and up over the prominence of the right bust apex to thestarting point avoiding constriction at the crotch.6.2.14 Total Crotch LengthMeasure the distance fromwaist level at the center front through the crotch and to

39、thewaist level at center back avoiding constriction at the crotch.6.2.15 Cervicale HeightMeasure the vertical distancefrom the cervicale to the floor.6.2.16 Head and Neck LengthMeasure the distance fromthe crown of the head to the cervicale (contour) taken with thehead erect and the neck unbent.6.2.

40、17 Center Back Waist LengthMeasure the distancefrom the cervicale to center back waist level along the spine.6.2.18 Center Front Waist LengthMeasure the distancefrom the center front neck base line to center front waist level.6.2.19 Scye DepthMeasure the vertical distance from thecervicale to the ba

41、ck-break point level. of the body (contour)then vertically to the floor.6.2.20 Waist HeightMeasure the distance from the waistlevel to the hip girth level along the side of the body (contour)then vertically to the floor.6.2.21 Waist to Hip HeightMeasure the vertical distancefrom the hip girth level

42、to the floor along the side of the body.6.2.22 Crotch HeightMeasure the vertical distance fromthe midpoint of the crotch to the floor.6.2.23 Knee HeightMeasure the vertical distance from themidpoint of the back of the knee (or crease) to the floor.6.2.24 Ankle HeightMeasure the vertical distance fro

43、mthe prominence of the outer ankle bone to the floor.6.2.25 Shoulder LengthMeasure the distance from theside of the neck base to the top of the shoulder joint.6.2.26 Back WidthMeasure the horizontal distance acrossthe back from back-break point to back-break point over theshoulder blades.6.2.27 Fron

44、t Chest WidthMeasure the horizontal distanceacross the chest from front-break point to front break point.6.2.28 Arm LengthMeasure the distance from the top ofthe shoulder joint along the outside of the arm over the elbowto the prominent wrist bone.6.2.29 Shoulder and Arm LengthMeasure the distancefr

45、om the side of the neck base across the shoulder joint andalong the outside of the arm over the elbow to the prominentwrist bone.6.2.30 Cervicale to WristMeasure the distance from thecervicale over the top of the shoulder joint, along the outside ofthe arm over the elbow to the prominent wrist bone.

46、6.2.31 Shoulder SlopePosition the goniometer on theshoulder and move the baseline until it is parallel to the floor;identify on the dial the rad (degrees) of difference between theshoulder slant and the horizontal measure of the goniometer.7. Keywords7.1 apparel; body measurements; boys; garment siz

47、es;husky; tablesASTM International takes no position respecting the validity of any patent rights asserted in connection with any item mentionedin this standard. Users of this standard are expressly advised that determination of the validity of any such patent rights, and the riskof infringement of

48、such rights, are entirely their own responsibility.This standard is subject to revision at any time by the responsible technical committee and must be reviewed every five years andif not revised, either reapproved or withdrawn. Your comments are invited either for revision of this standard or for additional standardsand should be addressed to ASTM International Headquarters. Your comments will receive careful considera