DLA A-A-52115 C-1996 SWEATER MAN-S OLIVE DRAB《橄榄褐色男式毛衣》.pdf

1、A-A-52LL5C m 9999974 o372933 733 rn I INCH-POUND I SUPERSEDING A-A-52115C November 5,1996 A-A-5211% July 29,1993 COMMERCIAL ITEM DESCRIPTION SWEATER, MANS, OLIVE DRAB The General Services Administration has authorized the use of this commercial item for all Federal agencies. 1. SCOPE. This commercia

2、l item description covers the requirements for a knitted, acrylic pullover mans sweater intended for use by Military personnel in cold weather climates. 2. CLASSIFICATION. The sweater shall be available in the following sizes: X-Small Small Medium Large X-Large XX-Large (30-32) (34-36) (3840) (42-44

3、) (46-48) (50-52) 3. SALIENT CHARACTERISTICS. 3.1 Descriution. The sweater shall be a knitted pullover with a convertible collar, five-button, V-style front yoke opening, reinforced shoulders and armholes, and long sleeves. The component parts shall be cut in accordance with the contractors pattern

4、from the same piece of material. The length of parts shall run in the wale direction, except for the collar and yoke. The yoke, buttons, and buttonholes shall be reinforced with a sufficiently wide polyester or polyester blend plain weave or twill cloth. The yoke reinforcement shall be attached usin

5、g good commercial practices. The gimp used for the buttonholes shall be any suitable cotton thread dyed to approximate the shade of the basic material. 3.2 Material. The fiber for the sweaters shall be 100 percent acrylic high bulkhelaxed fiber having low pill properties. The low pill fiber is desig

6、nated as S-63 (TM) acrylic fiber or equal (See 7.3). The yarn count shall be 2/24 or 2/23 worsted count. The yam shall be either skein, package, or producer dyed to meet the standard sample for shade of the knitted fabric. Beneficial comments, recommendations, additions, deletions, clarifications, e

7、tc., and any data which may improve this document should be sent to: Defense Personnel Support Center, Clothing and Textiles Directorate, Attn: DPSC-FNS, 2800 South 20th Street, Philadelphia, PA I 19145-5099. AMSC N/A FSC 8405 DISTRIBUTION STATEMENT A. Approved for public release; distribution is un

8、limited. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-52LL5C 9999974 0372934 67T = A-A-52115C Component parts Body L/ Sleeves - 1/ Cuffs z/ Skirt 2/ Collar and yoke 3.2.1 Knitted fabrics. The knitted component parts of the sweater shall confor

9、m to the requirements specified in Table I. Stitch type Wales per inch (minimum) Courses per inch (minimum) Jersey 8 10 Jersey 8 10 2x2 rib 8 14 2x2 rib 8 14 1x1 rib 12 20 TABLE I. Requirements for knitted fabrics Characteris tic Acrylic Requirement Test Method 1 O0 percent AATCC 20A 3.2.2 Physical

10、reuuirements. The body material shall conform to the requirements specified in Table II. Good L/ Good I/ 3.5 min. 2/ Good I/ TABLE II. Material requirements AATCC 16, Option A AATCC 132 AATCC 8 AATCC 61-3A Perspiration Pilling pH Bursting strength (lbs., min.) Shrinkage or elongation (percent, max.)

11、, length or width Colorfastness to: Light Laundering Dry cleaning Crocking Good I/ AATCC 15 3.5 min. 31 ASTM-D-35 12 4.0 - 8.0 FED-STD- 19 1, TM 28 1 1 80 ASTM-D-3787 6.0 AATCC 135 3.2.3 Thread. The thread used for seaming and stitching shall be 100 percent cotton, 40 or 50 Tex, 3-ply. As an alterna

12、te, a polyester core, cotton covered yarn, 50 Tex, 2 or 3 ply or 40 Tex 2 ply may be used. The thread shall be dyed to approximate the shade of the knitted fabric or dyed to match Olive Drab S- 1, C.A. 66022 or Olive Drab T- 1, C.A. 66023. The dyed thread shall show a minimum of “good“ colorfastness

13、 to laundering (AATCC 61, Test 3A), wet-dry cleaning (AATCC 132), and perspiration (AATCC 15). 3.2.4 TaDe reinforcement. The tape for reinforcing the shoulders and the bottom of the armhole shall be a plain weave cotton, 1/2 1/32 inch in width, 35 pounds minimum warp strength, and 2 Provided by IHSN

14、ot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-52115C 9999974 0372935 50b Large 42-44 X-Large 46-48 XX-Large 50-52 Tolerance A-A-52115C 20 27 8 9-1/2 23 9- 1/2 3-1/2 6-1/2 22 28 8 9-1/2 23-1/2 9-1/2 3-1/2 7 24 29 8-1/2 9-1/2 24 10 3-1/2 7 +1 +1 + 1/2 - 1/2 + 1

15、- 1/2 + 1 * 1/2 + 1/4 -0, + 1/2 58 pounds minimum filling yarns per inch. The tape shall be dyed to approximate the shade of the knitted fabric. 3.3 Label. Each sweater shall have a combination size, identification and instruction label for garments, made of either nonwoven, spunbound polyester or n

16、onwoven, 80/20 polyester/cellulose cloth. The label shall be coated with an acrylic coating that does not contain skin irritants, toxic materials or materials that support mildew growth. The label shall show “good“ colorfastness to accelerated laundering, and shall contain the following information:

17、 SWEATER, MANS, OD FIBER CONTENT: 100% ACRYLIC CONTRACT NUMBER NSN SIZE NAME OF CONTRACTOR LAUNDERING INSTRUCTIONS: WASH IN WARM WATER 80 k 50F, KNIT CYCLE. TUMBLE DRY, LOW HEAT, REMOVE PROMPTLY. DO NOT USE CHLORINE BLEACH. 3.3.1 Labeytag. Each item shall be individually bar-coded with a pressure-se

18、nsitive label or paper tag. The finish of the labeytag shall be compatible with printing technology used. The labeytag shall be readable by a scanner. The bar coding element shall be a 13 digit national stock number (NSN), and shall be located so that it is completely visible on the item when it is

19、folded andor packaged as specified. 3.4 Finished measurements. The finished sweater shall conform to the measurements specified in Table III. TABLE III. Finished measurements (inches) A. Measure across front, approximately 1 inch below armhole seams, folded edge to folded B. Measure down front from

20、shoulder seam at collar to bottom edge of sweater. C. Measure across neck opening from shoulder seam to shoulder seam of collar. D. Measure along folded edge of left front yoke seamline at bottom to collar seamline at top. edge. 3 Provided by IHSNot for ResaleNo reproduction or networking permitted

21、without license from IHS-,-,-A-A-SZLLSC m 9999974 OL7293b 442 = A-A-52115C E. Measure along folded edge of sleeve, from the intersection of the armhole seam and shoulder F. Measure from the intersection of the armhole section and shoulder seam at top on a straight G. Measure on a straight line acros

22、s center, from folded edge to folded edge. H. Measure across width of sleeve from folded edge to sleeve seam at a point 10 inches from seam to the bottom edge of the cuff. line to the intersection of the armhole and inseam at bottom. bottom of armhole along sleeve seam. - 1/ The tolerances from the

23、armhole lengths and sleeve length shall be consistent. A plus tolerance in one measurement and a minus tolerance in another will not be permitted. 3.5 Weights. The weight of the finished sweaters shall be as specified in Table IV, and tested in accordance with ASTM-D-3776. TABLE IV. Weight (Dounds)

24、Weight/dozen X-Small Small Medium Large X-Large XX-Large (minimum) 9 10-1/2 12 13-1/2 15 16-1/2 4. REGULATORY REQUIREMENTS. The offeror/contractor is encouraged to use recovered materials to the maximum extent practicable, in accordance with paragraph 23.403 of the Federal Acquisition Regulation (FA

25、R). 5. OUALITY ASSURANCE PROVISIONS 5.1 Product conformance. The products offered shall meet the salient characteristics of this commercial item description, conform to the producers own drawings, specifications, standards, and quality assurance practices, and be a similar product that is offered fo

26、r sale in the commercial market. The Government reserves the right to require proof of such conformance. 5.2 Market acceDtance criteria. The item offered, or a generic equivalent, must have been sold to the commercial market or to the Government. 5.3 Visual examination. The sweater shall be examined

27、 for the defects listed below. 5.3.1 Defects. Barre; any hole, cut, tear, color not as specified; any spot or stain (outside); raw edges; open seams; thread ends not removed; loose tension resulting in loose seams; any material defects; any repairs; distorted parts or poor workmanship; any component

28、 part omitted; label missing, incorrect, or illegible; measurement of item not as specified; bar code omitted or not readable by scanner; human-readable interpretation (HRI) omitted or illegible; bar code not visible on folded, packaged item; bar code causes damage to the item; any items not package

29、d in accordance with the contract or purchase order. 5.4 Acceptance criteria. Acceptance criteria shall be as specified in the contract or purchase order. 6. PACKAGING 6.1 Preservation. packing, and marking. The preservation, packing, and marking shall be as specified in the contract or purchase ord

30、er. 4 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-52115C m 9999974 0372937 389 m A-A-52115C I 7. NOTES 7.1 Source of Government documents. Copies of military and Federal documents are available from: Standardization Documents Order Desk Bldg.

31、 4D 700 Robbins Avenue Philadelphia, PA 19 1 1 1-5094 7.2 Source of non-Government documents ASTM Test Methods (Applications for copies should be addressed to American Society For Testing and Materials (ASTM), 100 Barr Harbor Drive, West Conshohocken, PA 19428-2959.) AATCC Test Methods (Applications

32、 for copies should be addressed to American Association of Textile Chemists and Colorists (AATCC), P.O. Box 12215, Triangle Park, NC 27709-2215.) 7.3 S-63 fiber is a trademark of Monsanto Chemical Companys low-pill acrylic fiber and meets the requirements of this commercial item description. MILITAR

33、Y INTEESTS: Custodians: Army - GL Air Force - 99 Navy - NU Review Activities: Air Force - 45,82 Arrny-MD CIVIL AGENCY COORDINATING ACTIVITY: GSA - FSS PREPARING ACTIVITY: DLA - CT Project 8405-0301 5 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,- A-A-52335C 9993974 0372938 235 W A-A-52115C ? PIaUIRE I. SWEATEBR, MAWS, OLIVE BDIRABC 6 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-