DLA A-A-55469 2 B-2012 CONNECTORS ELECTRICAL PLUGS TIP DUAL (BANANA PLUG).pdf

1、 AMSC N/A FSC 5935 INCH-POUND A-A-55469/2B 21 August 2012 SUPERSEDING A-A-55469/2A 17 July 2002 COMMERCIAL ITEM DESCRIPTION SPECIFICATION SHEET CONNECTORS, ELECTRICAL, PLUGS, TIP, DUAL (BANANA PLUG) The General Services Administration has authorized the use of this commercial item description for al

2、l federal agencies. The complete requirements for acquiring the connectors described herein shall consist of this document and the issue in effect of A-A-55469. CLASSIFICATION/PART or IDENTIFICATION NUMBER (PIN). This commercial item description (CID) specification sheet uses a classification system

3、 which is included in the PIN as shown in the following example (see NOTES). AA55469 /02 - 01 CID number Applicable Dash number CID specification (see table I) Sheet (two digits) TABLE I. Design and identification data. Dash number AA55469/02 Color Current rating (amperes, maximum) Contact resistanc

4、e (milliohms, maximum) 01 and 03 Black 15 10 02 and 04 Red 15 10 SALIENT CHARACTERISTICS. Interface and physical dimensions. Connectors, electrical, plugs, tip, dual (banana plug) supplied to this CID specification sheet shall be as specified herein (see figure 1). CID sheet. The electrical connecto

5、rs shall be in accordance with the requirements specified herein in addition to the salient characteristics of A-A-55469. Design, construction, and dimensions. Design, construction, and dimensions shall be as specified on figure 1 and table I. Contact current rating. Contact current rating shall be

6、as specified in table I. Contact resistance. Contact resistance shall be as specified in table I. Inactive for new design after 21 August 2012. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-55469/2B 2 AA55469/02-01 and AA55469/02-02 FIGURE 1. C

7、onfiguration and dimensions. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-55469/2B 3 A-A55469/02-03 and A-A-5546902-04 Inches mm Inches mm .005 0.127 .56 14.2 .010 0.25 .750 19.05 .015 0.38 .906 23.01 .165 4.19 1.00 25.4 .170 4.32 1.06 26.97 .

8、190 4.83 1.10 27.9 .195 4.95 1.28 32.5 .36 9.1 1.53 38.9 .53 13.5 1.78 45.2 .531 13.49 NOTES: 1. Dimensions are in inches. 2. Metric equivalents are given for information only. 3. Unless otherwise specified, tolerances are .010 (0.25 mm) for three-place decimals and .03 (0.08 mm) for two-place decim

9、als. 4. When set screw is used, the head shall be below the surface of the insulating material. FIGURE 1. Configuration and dimensions Continued. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-55469/2B 4 Dielectric withstanding voltage (at sea l

10、evel). Dielectric withstanding voltage (at sea level) shall be 3,000 V rms at 60 Hz or 5,000 V dc. Operating voltage. Operating voltage is 300 volts rms, 60 hertz at sea level. Marking. Test point connectors supplied to this CID shall be marked with the manufacturers standard commercial PIN. QUALITY

11、 ASSURANCE PROVISIONS. Shall be as specified in CID A-A-55469. Certificate of compliance. Each contractor desiring to be listed as a suggested source of supply shall submit a DSCC certificate of compliance to DSCC-VAI. This certificate shall state that the contractors product meets all the requireme

12、nts of this CID. In addition, a certificate of compliance shall accompany all test point connectors supplied to this CID. NOTES. PIN. The PIN should be used for government purposes to buy commercial products to this CID specification sheet. See the classification section for PIN format example. Sour

13、ce document. Commercial Item Description A-A-55469 - Connectors, Electrical, Plugs. (Copies of CIDs are available from the Defense Printing Service Detachment Office, Building 4D (Customer Service), 700 Robbins Avenue, Philadelphia, PA 19111-5094.) Government users. To acquire information on obtaini

14、ng these test pint connectors from the Government inventory system, contact Defense Supply Center Columbus, ATTN: DSCC-VAI, 3990 East Broad Street, Columbus, OH 43216-5000. Ordering data. Ordering data shall be as specified in A-A-55469. Supersession data. This CID supersedes MIL-C-28901/2. Suggeste

15、d sources of supply. Suggested sources of supply are listed below. Additional sources will be added as they become available. The vendors listed have submitted a certificate of compliance to DSCC-VAI and meet the market acceptability requirements of this CID. Dash number (see table I) AA55469/02- Ve

16、ndor commercial PIN CAGE 91967 Vendor commercial PIN CAGE 74970 Applicable NSN 01 210-103 - 5935-00-931-0380 02 210-102 - 5935-00-140-3354 03 - 108-0203-001 5935-00-007-8602 04 - 108-0202-001 5935-00-567-0521 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from I

17、HS-,-,-A-A-55469/2B 5 Commercial products. As part of the market analysis and research effort, this CID specification sheet was coordinated with the following manufactures of commercial products. At the time of CID specification sheet preparation and coordination, these manufactures were known to ha

18、ve commercial products that would meet the requirements of this CID specification sheet. (NOTE: this information should not be considered as a list of approved manufacturers or be used to restrict procurement to only the manufacturers shown.) Vendor CAGE Vendor name number and address 74970 E.F. Joh

19、nson 299 Johnson Avenue Waseca, MN 56093 91967 Abbatron 632 Arch Street Meadville, PA 16335 Changes from previous issue. Marginal notations are not used in this revision to identify changes with respect to the previous issue due to the extensiveness of the changes. MILITARY INTERESTS: CIVIL AGENCY C

20、OORDINATING ACTIVITY: Custodians: GSA - 7FXE Army CR Navy EC Air Force 85 DLA CC Preparing Activity: Review activities: DLACC Army AR, CR4, MI Navy AS, CG, MC, OS (Project 5935-2012-108) Air Force 19 NOTE: The activities listed above were interested in this document as of the date of this document. Since organizations and responsibilities can change, you should verify the currency of the information above using the ASSIST Online database at https:/assist.dla.mil. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-