DLA MIL-PRF-22885 12 H-2010 SWITCH SUBASSEMBLY COLOR FILTERS (FOR SWITCH PUSH BUTTON ILLUMINATED).pdf

1、AMSC N/A FSC 5930 INCH-POUND MIL-PRF-22885/12H 4 June 2010 SUPERSEDING MIL-PRF-22885/12G 26 April 2004 PERFORMANCE SPECIFICATION SHEET SWITCH, SUBASSEMBLY, COLOR FILTERS (FOR SWITCH, PUSH BUTTON, ILLUMINATED) This specification sheet is approved for use by all Departments and Agencies of the Departm

2、ent of Defense. The requirements for acquiring the color filters described herein shall consist of this specification sheet and MIL-PRF-22885. NOTES: 1. Dimensions are in inches. 2. Unless otherwise specified, tolerance is .010 (0.25 mm). 3. Metric equivalents are given for general information only.

3、 FIGURE 1. Design and construction. Inches mm .037 .067 .088 .230 .275 .281 .290 .325 0.94 1.70 2.24 5.84 6.99 7.14 7.37 8.26 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-22885/12H 2 Design and construction: See figure 1. Intended use: For

4、 use with 4-lamp (T-1 midget flanged base) illuminated push button switches of MIL-PRF-22885/9, MIL-PRF-22885/15 and MIL-PRF-22885/87. Classification: See MIL-PRF-22885/9, MIL-PRF-22885/15 and MIL-PRF-22885/87. Illuminated color: See table I. Spectrographic method shall be used. Luminance: See table

5、 I. Marking: Identification marking shall be on unit package or tag. Inspection: Group A: Inspection for dimensions. Group B and qualification: As part of MIL-PRF-22885/9, MIL-PRF-22885/15 or MIL-PRF-22885/87 switch inspection. One additional sample (4 color filters) per color required for color fad

6、e test. TABLE I. Illuminated color and luminance. Colors Illuminated color chromaticity limits 1/ Switch luminance (foot-lamberts) 2/ 2360 Kelvin 4 lamps illuminated 2 lamps illuminated x y Minimum Maximum Minimum Red .695 .703 .655 .660 .285 SL 3/ .325 SL 3/ 50 100 20 Green .260 .300 .160 .200 .570

7、 .630 .660 .720 50 100 20 Yellow .562 .570 .596 .605 .415 SL 3/ .382 SL 3/ 100 200 40 Blue .150 .220 .220 .150 .260 .260 .320 .320 8 40 4 White .400 .460 .400 .460 .420 .420 .380 .380 100 200 40 1. The chromaticities of the diffusing lenses or colored filters expressed as x and y coordinates on the

8、CIE chromaticity diagram shall lie within areas bounded by the coordinates listed for each color, using a source illuminate of 2360 K. 2. Switch photometric brightness, when viewed from the front of the applicable switch indicator light. 3. SL - Spectrum locus (where intersected by other coordinate

9、pair). Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-22885/12H 3 Color fade test: Four T-1 midget flange base lamps, industry number 328, or equivalent shall be installed in the test fixture. The test fixture shall operate at 5 0.2 volts co

10、ntinuously for a period of 300 hours at room ambient. At the completion of this test, the colors must remain within the limits specified in table I. The color fade test fixture shall consist of one MIL-PRF-22885/10 or MIL-PRF-22885/16 modular indicator light for each color of filter to be tested, mo

11、unted in a suitable panel. Part number: M22885/12- (dash number from table II). TABLE II. Dash number and color code. Dash number Color Code 01 02 03 04 05 Blue Green Red White Yellow B G R W Y Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-

12、22885/12H 4 Reference Documents: MIL-PRF-22885 MIL-PRF-22885/9 MIL-PRF-22885/10 MIL-PRF-22885/15 MIL-PRF-22885/16 MIL-PRF-22885/87 The margins of this specification are marked with vertical lines to indicate where modifications from this revision were made. This was done as a convenience only and th

13、e Government assumes no liability whatsoever for any inaccuracies in these notations. Bidders and contractors are cautioned to evaluate the requirements of this document based on the entire content irrespective of the marginal notations. Custodians: Preparing activity: Army - CR DLA - CC Navy - EC A

14、F - 85 (Project 5930-2009-019) DLA - CC Review activities: Army - AT, AV, CR4, MI Navy - AS, MC, OS Air Force 99 NOTE: The activities listed above were interested in this document as of the date of this document. Since organizations and responsibilities can change, you should verify the currency of the information above using the ASSIST Online database at https:/assist.daps.dla.mil/ . Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-