EN 60335-2-37-2002 en Household and similar electrical appliances - Safety Part 2-37 Particular requirements for commercial electric deep fat fryers (Incorporating corrigendum Augu.pdf

1、BRITISH STANDARDBS EN 60335-2-37: 2002+A12:2016Incorporating corrigendum August 2007Household and similar electrical appliances SafetyPart 2-37: Particular requirements for commercial electric deep fat fryersICS 97.040.50nullnull nullnullnullnullnullnullnull nullnullnullnullnullnullnull nullnullnull

2、 nullnullnullnullnullnullnullnullnullnull nullnullnullnullnullnull nullnull nullnullnullnullnullnullnullnullnull nullnull nullnullnullnullnullnullnullnullnull nullnullnullNational forewordThis British Standard is the UK implementation of EN 60335-2-37:2002+A12:2016, incorporating corrigendum August

3、2007. It is derived from IEC 60335-2-37:2002, incorporating amendment 1:2008. It supersedes BS EN 60335-2-37:2002+A11:2012 which will be withdrawn on 25 January 2019.The start and finish of text introduced or altered by amendment is indicated in the text by tags. Tags indicating changes to IEC text

4、carry the number of the IEC amendment. For example, text altered by IEC amendment 1 is indicated by !“.Where a common modification has been introduced by amendment, the tags carry the number of the amendment. For example, the common modifications introduced by CENELEC amendment A11:2012 are indicate

5、d by hi.The UK participation in its preparation was entrusted to Technical Committee CPL/61, Safety of household and similar electrical appliances.A list of organizations represented on this committee can be obtained on request to its secretary.This publication does not purport to include all the ne

6、cessary provisions of a contract. Users are responsible for its correct application.Compliance with a British Standard cannot confer immunity from legal obligations.BS EN 60335-2-37:2002+A12:2016This British Standard waspublished under the authorityof the Standards Policy andStrategy Committeeon 29

7、January 2003 The British Standards Institution 2016. Published by BSI Standards Limited 2016ISBN 978 0 580 91862 9Amendments/corrigenda issued since publicationAmd. No. Date Comments 17466Corrigendum No. 130 November 2007 Implementation of CENELECcorrigendum August 2007. Lastparagraph of EN foreword

8、 replaced.Addition to Annex ZB deleted30 September 2008 Implementation of IEC amendment1:2008 with CENELEC endorsementA1:200831 May 2012 Implementation of CENELEC amendment A11:201230 April 2016 Implementation of CENELEC amendment A12:2016EUROPEAN STANDARD EN 60335-2-37:2002+A12NORME EUROPENNE EUROP

9、ISCHE NORM CENELEC European Committee for Electrotechnical Standardization Comit Europen de Normalisation Electrotechnique Europisches Komitee fr Elektrotechnische Normung Central Secretariat: rue de Stassart 35, B - 1050 Brussels 2002 CENELEC - All rights of exploitation in any form and by any mean

10、s reserved worldwide for CENELEC members.Ref. No. EN 60335-2-37:2002 EICS 97.040.50 English version Household and similar electrical appliances - SafetyPart 2-37: Particular requirements for commercial electric deep fat fryers (IEC 60335-2-37:2002)Appareils lectrodomestiques et analogues - Scurit Pa

11、rtie 2-37: Rgles particulires pour les friteuses lectriques usage collectif(CEI 60335-2-37:2002)Sicherheit elektrischer Gerte fr den Hausgebrauch und hnliche Zwecke Teil 2-37: Besondere Anforderungen fr elektrische Friteusen fr den gewerblichen Gebrauch (IEC 60335-2-37:2002)This European Standard wa

12、s approved by CENELEC on 2002-12-01. CENELEC members arebound to complywith the CEN/CENELEC Internal Regulations which stipulate the conditions for giving this European Standard the status of a national standard without any alteration. Up-to-date lists and bibliographical references concerning such

13、national standards may be obtained on application to the Central Secretariat or to any CENELEC member. This European Standard exists in three official versions (English, French, German). A version in any otherlanguage made by translation under the responsibility of a CENELEC member into its own lang

14、uage and notified to the Central Secretariat has the same status as the official versions. CENELEC members are the national electrotechnical committees of Austria, Belgium, Czech Republic, Denmark, Finland, France, Germany, Greece, Hungary, Iceland, Ireland, Italy, Luxembourg, Malta, Netherlands, No

15、rway, Portugal, Slovakia, Spain, Sweden, Switzerland and United Kingdom. Incorporating corrigendum August 2007March 2016Foreword The textof document 61E/399/FDIS, future fifth edition of IEC 60335-2-37, prepared by SC 61E of the IEC Technical Committee 61, was submitted to the IEC-CENELEC parallel v

16、ote and was approved byCENELEC as EN 60335-2-37 on 2002-12-01. This European Standard replaces EN 60335-2-37:2000. The following dates are applicable: -latest date by which the EN has to be implemented at national level by publication of an identical national standard or by endorsement (dop) 2003-09

17、-01 -date on which national standardsconflicting with the EN have to be withdrawn (dow) 2005-12-01 This part 2 has to be used in conjunction with EN 60335-1, Household and similar electrical appliances Safety Part 1: General requirements. It was established on the basis of the 2002 edition of that s

18、tandard. Amendments and revisions of Part 1 have also to be taken into account and the dates when such changes become applicable will be stated in the relevant amendment or revision of Part 1. This part 2 supplements or modifies the corresponding clauses of EN 60335-1, so as to convert it into the E

19、uropean Standard: Safety requirements for commercial electric deep fat fryers. When a particular subclause of Part 1 is not mentioned in this part 2, that subclause applies as farasisreasonable. When this standard states “addition“, “modification“ or “replacement“, the relevant text ofPart 1 is to b

20、e adapted accordingly.NOTE 1 The following numbering system is used:- subclauses, tables and figures that are numbered starting from 101 are additional to those in Part 1;- unless notes are in a new subclause or involve notes in Part 1,they are numbered starting from 101, including those in a replac

21、ed clause or subclause;- additional annexes are lettered AA, BB, etc.;- subclauses, notes and annexes that are additional to those in the IEC standard are prefixed with the letter Z.NOTE 2 The following print types are used:- requirements: in roman type; - test specifications: in italic type ;- note

22、s: in small roman type.Words in bold in the text are defined in Clause 3. When a definition concerns an adjective, the adjective and the associated noun are also in bold.There are no special national conditions causing a deviation from this European Standard, other than those listed in Annex ZA to E

23、N 60335-1. _ There are no national deviations from this European Standard, other than those listed in Annex ZB toEN 60335-1.Page 2BS EN 60335-2-37:2002+A12:2016EN 60335-2-37:2002+A12:2016 (E)Page 3Introduction _ Endorsement notice The text of the International Standard IEC 60335-2-37:2002 was approv

24、ed by CENELEC as a European Standard without any modification. _ ABZ xenn (ifnroitamv)eA-vedisnoita :noitiddA sualCe veDiitaon51.7 uAstria (Ekeltrsocztuhvrero- 5991 gnund GBrN .lB)51.7 ,5991/607 .fI m ehtrakfo gni fixcnailppa dese si siv tonifa elbret cnailppa ehtsah e sni neebt,della eht retnavel f

25、niorms noitasla llaho cni eblsni eht ni dedutructsnoi for sulanoitidda na no dna e w lebalcihc hf eb naixraen de cnailppa ehtfa eret snit.noitalla _ The text of document 61E/595/FDIS, future amendment 1 to IEC 60335-2-37:2002, prepared bySC 61E, Safety of electrical commercial catering equipment, of

26、 IEC Technical Committee 61, Safety of household and similar electrical appliances, was submitted to the IEC-CENELEC parallel vote and was ap proved byCENELEC as amendment A1 to EN 60335-2-37:2002 on 2008-03-01.The following dates are applicable:-latestdate by which the amendment has to beimplemente

27、d at national level bypublication ofan identical national standard or by endorsement (dop) 2008-12-01-date on which national standards conflicting with the amendment have to be withdrawn(dow) 2011-03-01This amendment supplements or modifies the corresponding clauses of EN 60335-2-37:2002.There are n

28、o special national conditions causing a deviation from this amendment. There are no national deviations from this amendment. _Endorsement noticeThe text of amendment 1:2008 to the International Standard IEC 60335-2-37:2002 was approved byCENELEC as an amendment to the European Standard without any m

29、odification. Foreword to amendment A1In the Bibliography, add the following note to the standard mentioned:ISO 13732-1 NOTE Harmonized as EN ISO 13732-1:2006 (not modified)._BS EN 60335-2-37:2002+A12:2016EN 60335-2-37:2002+A12:2016 (E)The principle objectives of Low Voltage Directive, 2006/95/EC, ar

30、e covered in this standard. The essential safety requirements of the Machinery Directive 2006/42/EC have also been taken into account for appliances covered by this part. hiForeword to amendment A11 This document (EN 60335-2-37:2002/A11:2012) has been prepared by CLC/TC 61, “Safety of household and

31、similar electrical appliances“. The following dates are fixed: latest date by which the amendment has to be implementedat national level by publication of an identicalnational standard or by endorsement (dop) 2012-12-21 latest date by which the national standards conflictingwith the amendment have t

32、o be withdrawn (dow) 2014-12-21 This amendment supplements or modifies the corresponding clauses of EN 60335-1:2012, EN 60335-2-37:2002 and EN 60335-2-37:2002/A1:2008. Attention is drawn to the possibility that some of the elements of this document may be the subject of patent rights. CENELEC and/or

33、 CEN shall not be held responsible for identifying any or all such patent rights. This document has been prepared under a mandate given to CENELEC by the European Commission and the European Free Trade Association, and supports essential requirements of EU Directive(s). For the relationship with EU

34、Directive(s) see informative Annex ZZ, which is an integral part of this document. Page 4BS EN 60335-2-37:2002+A12:2016EN 60335-2-37:2002+A12:2016 (E)This document (EN 60335-2-37:2002/A12:2016) has been prepared by CLC/TC 61 “Safety of household and similar electrical appliances“. The following date

35、s are fixed: latest date by which this document has tobe implemented at national level bypublication of an identical nationalstandard or by endorsement(dop) 2017-01-25 latest date by which the national standardsconflicting with thisdocument have to be withdrawn(dow) 2019-01-25 Attention is drawn to

36、the possibility that some of the elements of this document may be the subject of patent rights. CENELEC and/or CEN shall not be held responsible for identifying any or all such patent rights. This document has been prepared under a mandate given to CENELEC by the European Commission and the European

37、 Free Trade Association, and supports essential requirements of EU Directive(s). For the relationship with EU Directive see informative Annex ZZ, which is included in EN 60335-2-37:2002/A11:2012. This standard covers the Principle Elements of the Safety Objectives for Electrical Equipment Designed f

38、or Use within Certain Voltage Limits (LVD - 2006/95/EC). Foreword to amendment A12 CONTENTSINTRODUCTION 61Scope 72Normative references. 73Definitions . 74General requirement 85General conditions forthe tests. 86Classification. 97Marking andinstructions 98Protection against access to live parts119Sta

39、rting of motor-operatedappliances 1110 Power input andcurrent1111 Heating.1112 Void 1213 Leakagecurrent and electric strengthatoperating temperature1214 Transient overvoltages1315 Moisture resistance.1316 Leakagecurrent and electric strength.1517 Overload protection of transformersand associated cir

40、cuits1518 Endurance1519 Abnormal operation. 1520 Stabilityand mechanical hazards1621 Mechanicalstrength1622 Construction .1623 Internal wiring.2024 Components.2025 Supplyconnectionand external flexible cords.2027 Provision for earthing2128 Screws and connections.2130 Resistancetoheatand fire.2131 Re

41、sistance to rusting2232 Radiation, toxicityand similarhazards2229 Clearances,creepage distancesand solidinsulation2126 Terminals forexternalconductors.21Page 5BS EN 60335-2-37:2002+A12:2016EN 60335-2-37:2002+A12:2016 (E)AnnexesFigure 101 Splash apparatus .AnnexN (normative) Proof tracking test.24Bib

42、liography. 272324Annex ZE (normative) Specific additional requirements for appliances and machines with power driven moving parts and intended for commercial use 24 Annex ZZ (informative) Coverage of Essential Requirements of EU Directives 26 hiINTRODUCTIONIt has been assumed in the drafting ofthisI

43、nternational Standard that the execution of itsprovisions is entrusted to appropriately qualified and experienced persons.This standard recognizes the internationally accepted level of protection against hazards suchas electrical, mechanical, thermal, fire andradiation ofappliances when operated as

44、innormal use takinginto account the manufacturers instructions. It also covers abnormalsituations that canbeexpectedinThis standard takes into account the requirements of IEC 60364 as far as possible so thatthere is compatibility with the wiringrules when the appliance is connected to the supplymain

45、s. However, national wiring rules may differ.If an appliancewithin the scope of this standard also incorporates functions that are coveredby another part 2of IEC 60335, the relevant part 2 is applied to each function separately, asfar as is reasonable. If applicable, theinfluenceof one function on t

46、he other is takenintoaccount.An appliance that complies with the text of thisstandard will n ot necessarily be considered tocomply with the safety principlesofthe standard if, when examined and tested, it is found tohave otherfeaturesthat impair the level of safety covered bythese requirements.An ap

47、pliance employingmaterials orhavingforms of construction differing from those detailedin the requirements of this standard maybe examined and tested according to the intent oftherequirements and, iffound to besubstantiallyequivalent, maybe considered to complywith the standard.practiceand takesintoa

48、ccountthe way in which electro-magnetic phenomena canaffectthe safe operation of appliances. When a part 2 standard does notincludeadditional requirements to coverhazards dealt within Part1, Part 1 applies. NOTE 1 This means that the technical committees responsible for the part 2 standards have det

49、ermined that it isnot necessary to specify particular requirements for the appliance in question over and above the generalrequirements.This standard isa product family standard dealingwith the safety of appliancesand takesprecedence over horizontal andgeneric standards covering the same subject.NOTE 2 Horizontal and generic standards covering a hazard are not applicable si nce they have been taken intoconsideration when developing the general and particular requirements for the I