NAVY MIL-STD-1320-210-1982 TRUCKLOADING WALLEYE I GUIDED WEAPON IN SHIPPING& STORAGE CONTAINER CNU-356 E《制导武器在海运和储存CNU-356 E箱的装车》.pdf

1、8. AUTHORIZED AND RELEASED c I ,. i a MIL-STD-1320 -210 81 U 7777711 O070777 O M . s- 37-03 MILITARY STANDARD MIL-STD-1320-210 (NAVY) TRUCKLOADING 8 OCTOBER 1982 WALLEYE I GUIDED WEAPON IN SHIPPING AND STORAGE CONTAINER CNU-356/E Provided by IHSNot for ResaleNo reproduction or networking permitted w

2、ithout license from IHS-,-,-MIL-STD-1320 -210 1 m 7777711 0070778 2 m MIL-STD-13 20-210 (NAVY) GENERAL NOTES 1. THIS DOCUMENT GIVES DETAILED INSTRUCTIONS FOR TRUCKLOADING ;HE WALLEYE GUIDED WEAPON IN CONTAINER, SHIPPING 2. AND STORAGE CNU-356/E. THE PROCEDURES AND PRACTICES DESCRIBED HEREIN ARE INTE

3、NDED FOR 40 FT FLATBED TRAILERS OR 40 FT VAN TRAILERS. THE TRAILER AXLES SHALL BE LOCATED IN THE WESTERN POSITION (AT THE EXTREME REAR OF THE TRAILER). DO NOT USE TRAILERS WITH NON- NAILABLE FLOORS. EACH STACK OF CONTAINERS TWO OR MORE HIGH IS SECURED TOGETHER WITH TWO 1 1/4 X ,035 CROSS STRAPS. THE

4、SE STRAPS PASS THROUGH THE FORK POCKETS OF THE TOP CONTAINERS AND RETURN THROUGH THE FORK POCKETS OF THE CONTAINERS IMMEDIATELY BELOW THE TOP CONTAINER, ONLY CHAINS AND LOAD BINDERS SHALL BE USED FOR TIEDOWNS. (STEEL STRAPS ARE NOT AUTHORIZED). CHAINS, FITTINGS AND LOAD BINDERS SHALL MEET THE REQUIR

5、EMENTS OF THE GENERAL TRUCKLOADING DOCUMENT MIL-STD-13M AND BE APPLIED AS SHOWN IN THIS DOCUMENT, PAGES 3, 5 AND 7. 3. 4. pq CHAINS PASS UNDER CONTAINER POD THROUGH THE STACK FROM ONE SIDE OF THE TRAILER TO THE OTHER. i i 5. PRIOR TO LOADING THE TRAILER AND DURING THE PRELOADING INSPECTION REQUIRED

6、BY NAVWEPS OP 2165 AND REPORTED ON DD FORM 626, THE CHAINS, FITTINGS AND LOAD BINDERS SHALL BE INSPECTED FOR STRETCH, GOUGING, BENT LINKS, WEAR AND ANY OTHER NOTICEABLE DEFECTS. THE INSPECTOR SHALL CONFIRM THAT THE CHAINS AND LOAD BINDERS HAVE BEEN INSPECTED AND SHALL SO NOTE IN ITEM NO. 22 OF DD FO

7、RM 626, ANY DEFICIENCY SHALCBE CAUSE FOR REJECTION OF A CHAIN OR LOAD BINDER. THE MAXIMUM GROSS WEIGHT OF THE TRACTOR-TRAILER AND THE ALLOWABLE AXLE WEIGHTS ARE THE RESPONSIBILITY OF THE CARRIER. THE CARRIER WILL ADVISE THE SHIPPER OF THESE LIMITATIONS AND THE SHIPPER SHALL LOAD THE TRAILER IN SUCH

8、A MANNER THAT THE TRACTOR-TRAILER WILL NOT EXCEED THESE LIMITATIONS. AFTER BLOCKING AND BRACING HAS BEEN INSPECTED, ATTACH SHIPPING DOCUMENTS TO AN ACCESSIBLE AREA AND ATTACH “EXPLOSIVES A“ PLACARD TO BOTH SIDES, FRONT AND BACK OF TRAILER. 6. 7. 8. 9. UNLESS OTHERWISE SPECIFIED MATERIALS SHALL BE IN

9、 ACCORDANCE WITH THE GENERAL TRUCKLOADING DOCUMENT, MIL-STD-1320. FOR GENERAL TRUCKLOADING PROCEDURES REFER TO THE GENERAL TRUCKLOADING DOCUMENT MIL-STD-1320. FTL 40 FT TRAILER (FLATBED) 2ND PIECE TO 1ST IN LIKE MANNER. /A DETAIL 0 END BLOCKING (4 REQUIRED) PAGE 2 : L a Provided by IHSNot for Resale

10、No reproduction or networking permitted without license from IHS-,-,-MIL-STD-1320 -210 1 W 7777711 0070777 4 W 5 a . - . ”. 72 1 M IL-STD-13 20-21 O (NAVY) DETAIL 0 SEPARATOR ASSEMBLY (4 REQUIRED) ARROWS INDICATE NO END OF CONTAINERS 2 X 6 DOUBLED. NAIL 1ST PIECE TO TRAILER FLOOR W/l-lM NAIL EVERY 8

11、 INCHES. NAIL 2ND PIECE TO 1ST IN LIKE MANNER 2 X4 DOUBLED. NAIL 1ST PIECE TO TRAILER FLOOR W/4-16d NAILS. NAIL 2ND PIECE TO IST IN LIKE MANNER. TRUCKLOAD DATA NUMBER OF CONTAINERS . 12 NUMBER OF WEAPONS . 24 WEIGHT (APPROX) 36, 600 LBS FTL 40 FT TRAILER (FLATBED PAGE 3 Provided by IHSNot for Resale

12、No reproduction or networking permitted without license from IHS-,-,-MIL-STD-1320-210 (NAVY) LTL 40 FT TRAILER (FLATBED) 1. WHEN REQUIRED TO SHIP LESS-THAN-TRUCKLOAD, SELECT THE CORRECT LOAD PATTERN FOR THE NUMBER OF CONTAINERS TO BE SHIPPED FROM TABLE I. POSITION CONTAINERS ON TRAILER AS SHOWN IN T

13、ABLE, BLOCK AND TIEDOWN LADING USING THE PRINCIPLES SHOWN ON PAGES 3 AND 5 AND THE GENERAL DOCUMENT, MIL-STD-1320. 2. mi STACKS OF 4 AND 5 CONTAINERS REQUIRE 3 TIEDOWNS. STACKS OF 3 OR LESS CONTAINERS REQUIRE 2 TIEDOWNS. 3. WHEN CONTAINERS IN A STACK ARE HIGHER ON ONE SIDE OF THE STACK AS SHOWN IN L

14、OAD PLANS 7, 9 AND 11 CONTAINERS, THE TOP CONTAINER ON THE HIGH SIDE SHALL BE BOLTED TO THE LOWER CONTAINER (4 PUCES) AS SHOWN IN DETAIL D. 4. THE LTL PLAN SHOWN ON PAGE 5 IS THE CORRECT LESS-THAN-TRUCKLOAD FOR THE QUANTITY OF CONTAINERS SHOWN. THIS DOES NOT LIMIT SHIPMENTS TO THIS QUANTITY, SINCE L

15、TL SHIPMENTS MAY CONSIST OF A GREATER OR LESSER NUMBER OF CONTAINERS. LOAD PATTERN * NO. OF CONTAINERS + FWD TABLE I LOAD PATTERN * ii. OF CONTAINERS - FWD 2 X 6 DOUBLED. NAIL 1ST PIECE TO Q 8 INCHES. NAIL ZND PIECE TO 1ST IN LIKE MANNER. DETAIL END BLOCKING 4 REQUIRED ON PAGE 5 3 REQUIRED ON PAGE 6

16、 PAGE 4 LOAD PATTERN * NO. OF CONTAINERS FWD m 2z I I I I I * NUMBER IN RECTANGLE INDICATES NUMBER OF CONTAINERS IN A LAYER. ARROWS INDICATE NOSE END OF CONTAINER. SEE LTL NOTE 3 DETAIL Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,- MIL-STD-1320 -2

17、10 83 W 7777733 0070783 2 10 9 8 7 MIL-STD-1320-210 (NAVY) P BOLT 7/16-14 UNC X 2 1/2 4 SEE DETAIL D 8 SEE GENERAL NOTE 3 SEAL FOR 1 1/4STRAP CROSSSTRAP 1 1/4 X.035 X i7 FT 4 SEE GENERAL NOTE 3 CHAIN ,:I I IIT=q Provided by IHSNot for ResaleNo reproduction or networking permitted without license fro

18、m IHS-,-,-MIL-STD-1320 -210 1 W 9997911 0070783 b M 4- MIL-STD-1320-210 (NAVY) 1. 2. WHEN REQUIRED TO SHIP WALLEYE WEAPONS IN THE CNU-356/ CONTAINERS BY VAN, THE PRINCIPLES OF THIS DOCUMENT SHALL BE FOLLOWED. THE CONTAINERS AR END HANDLED WITH THE MK 45 HANDLIFT TRUCK. SHIPMENT IN VANS IS AUTHORIZED

19、 ONLY WHEN FLATBED EQUIPMENT IS NOT AVAILABLE AND MILITARY NECESSITY DICTATES THAT SHIFMENT SHALL BE MADE. AUTHORIZATION TO USE VANS SHALL BE OBTAINED FROM COGNIZANT AUTHORITY PRIOR TO LOADING. WEIGHT (APPROX) . . . . . . . . . . . . . . . . . . 6,100 LBS. I2XSX24 I 24 I SEE FIELD NOTE I 4 I SLEEPER

20、 I I I 2X6X39 3 SEE FIELD NOTE INTERMEDIATE I CROSSMEMBER 2 BACKUPCLEAT 2 x 6 x 36 112 18 SEE DETAIL F 1 I CROSSMEMBER I2X6X39 I9 I SEE DETAIL F I LISTOF MATERIALS AND NAILING DATA LTC 40 FT TRAILER (VAN) REVIEW ACTIVITIES: NAVY - OS, AS PREPARING ACTIVlT; NAVY - OS - (PROJECT NO, 8140-N555) PAGE 7 *U .S, GOVEF-NMENT PRINTXNG OFFICE: 1982-605-034/5645 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-