1、中华人民共和国纺织工业部部标准FJ 519-82本色棉维混纺纱线本标准适用于鉴定棉和维纶短纤维混用比例各为50肠的本色棉维混纺纱线的品质.1产品品种、规格1.1棉维棍纺纱线的粗细程度，以1000米纱线在公定回潮率时的重量(克)来表示，称为纱线号数(tex)1.2，股线公称号数用组成股线的单纱公称号数乘以股数来表示.棉维混纺纱线的公定回潮率。以维纶公定回潮率5.0肠和棉公定回潮率8.5呱按干重混纺比例加权平均计算，公定回潮率的小数点计算至二位，修约为一位.计算方法如下:5.5X50+8 .5X50 X100。肠一6.896棉维混纺纱线的标准重it;10。米纱线在公定回潮率时的标准重量(克)=7
2、XK10100米纱线的标准干燥重蛋(克)，_-15-10.68单纱和股线的最后成品设计号数必须与其公称号数相等，纺股线用的单纱设计号数，应保证股1.31.311.4线的设计号数与其公称号数相等.1.5棉维混纺纱线的号数系列及其10。米的标准重量规定如下。，.5.1棉维混纺纱的号数系列及其10。米的标准重量规定(见表1).1.0301.1241.1001.2001.2171.3111.4041.5001.4981.6001.5921,6851_7001.8001.7791.9001.873 2.0001.9662_100中华人民共和国纺织工业部1982-12-31发布1983-07-01实施F1
3、 519-82续表1公称号数系列标准干燥重童克/100米重且.52棉维混纺线的号数系列及其100米的标准重量规定(见表2).表2公称号数系列标准干澡重皿 克八00朱公定回潮串6,8%6;1淤最11K212x22.20013x214x215x22.0602.2742.4342.6222.8092_996一一一一一-.-一2.16x217x2一一.一一一一，气一:22x23.745 一一一，-3.933_4.1204_3074.23x24.4.4944.4.6825.4006008000002004006008000002004006008000008_690565,2A3 5.6005.4315
4、.6185.9936.36730x232x26.一一一.-一-一一34x28000004008005()5FJ519-92FJ2技术共求2.1棉维混纺纱的技术指标(见表3)表3品等指标品级指标重，偏差%等别曾妙孟t不匀串 %不大于a#9条干均匀度十块板评级比例(优:一:二:三) 不低于1克内楠结杂质粒数不多于经纱纬纱11-13(53 45)14-15(42-V39)上205019502,5优7:3:0:050士2.5士2.5280380185017503,00:7:3:000140170016003.70:0:7:3上215020502.5优?:3:0:050280-380195018503,
5、00:7:3:090110017003,72,50:0:7:314050竺7:3:0:0 16-20(36.29)上22502150上2,5一，.，卜一卜上2,52803800:，:3:0曲014020501900185018003,03,了0:0:7:321-30(28-19)上230021502,6优7:3:0:050280380210020003,00:7:3:0901195018503,70:0:7:31403234(18-17)上230021502,石优7:3:0:060士2,8280-380210020003,00:7:3:01105:13913503.70:0:7:31702.2
6、福维混舫线的技术指标(见表幻表4公称号效(英制支数)品等指标实际拈系数(19厘米)11 x 2-20况2(53/229/2)38048021x2-30x2(28/219/2)!等一显巫担董还些业巳一xf;r.!g*I级窄毛黔俐一佗罗一I_一_%_乱典应垂1%!别I经妙纬纱I不大于I不多于!三匕2650 2500 2.0鱼一5一二一2450 2300 2.5一g5 t 2.5目三2250 2100 3.0_二三100习匕_2700_ 2550 2.0，远一35二二二2500 2350 2.5二二，65 t 2.5止三2300 2150 3.0三三100_匕 2700 2550 2.0优40一二立
7、_2500 2350_2.5二二.75土2.5二2300 2150 3.0二115380-48032x2-34x2(18/2-17/2)380-480506FJ 519-822.3棉维混纺纱线的条千均匀度样照暂按GB 398-78本色棉纱线技术条件第6条第(7)款规定选用。2.4分等分级2.4.1棉维混纺纱线品等品级的评定以批为单位，规定以同品种一昼夜三班的生产量作为一批，调班日的加班可与其相邻批并批，按GB 403-78本色棉纱线试验方法进行试验.2.4.2棉维混纺纱线的品等低于二等指标者，作三等;品级低于二级指标者，作三级.2.5棉维混纺纱线品等、品级的评定方法:2.5.1棉维混纺纱线的品
8、等由品质指标、重童不匀率评定，当品质指标和重盘不匀率的品等不同时，按二项中最低的品等评定.2.5.2棉维混纺纱的品级由棉杂粒数、条干均匀度评定，当棉杂粒数和条干均匀度的品级不同时，按两项中最低的品级评定。但条干均匀度的优级批中不允许有二、三级板;一级批中不允许有三级板.棉维混纺线的品级由棉杂粒数一项评定.2.5.3棉维混纺纱线的重A偏差超出允许范围时，作为不合格.在混纺纱线原评等的基础上，顺降一等处理，但降至三等为止.2.6棉维混纺纱线重最偏差月度累计，应按产量进行加权平均(开台致不变，产量稳定，亦可采用算术平均计算)，全月生产在15批以下的品种，应控制在10.50肠及以内.2.7棉维混纺纱线
9、的纤维混坊比例，允许差异范围规定为土2肠，即棉为48-52肠，维纶为52-48肠，生产上应按规定混纺比例控制，维纶混纺比例分析方法按GB 2910-82二组分纤维混纺产品定量化学分析方法规定进行.2.8针织用纱，按同号纬纱各项技术标准考核.舀试脸方法3.1棉维混纺纱线的物理指标和外观疵点，均按GB 408-78本色棉妙线试脸方法进行试验，其温度和回潮率的修正系热见本标准附录。4位脸舰期4.1棉维混纺纱线的交接验收和复验按GB 405-78本色棉纱线脸收规则的规定进行，生产厂与便用部门双方另有协议者，按协议办理.石标志和包筑5.1棉维混纺纱线的标志和包装，按GB 404-78本色棉纱线包装和标志
10、，的规定进行.5.2棉维混纺纱线的原料代号，规定为c/v,棍纺比例按代号顺序编写，应为50/50,FJ 519-82附录A栩/维(50/50)续纱强力修正系橄裹(补充件)1,0921,0921,0921,0931,0931,0941,0961,0971,0991,1011,1031,1061,1091,1121,1151,1191,1231,1281,1321,1371,1431,1481,1541,1611,1671,1741,1821,1901,1981,2071,2161,0861,0811,0811,0811,0821,0831,0841,0851,0861,0881,0901,Q92
11、1,0951,0981,1011,1041,1081,1121,1161,1211,1261,1311,1361,1421,1491,1551,1621,1691,1771,1851,1941,2031,心761,0761,0761,0771,0781,0781,0801,0811,0831,0851,0871,0901,0921,0961,0991,1071;1071.1111,1151,1201,1251,1311,1371,1431,1491,1561,1631,1711,1791,0711,071:一:1,0711.0571.0571.057了口口U555Oon:一:1.0891.06
12、11.0611.0621.0621.0631.0641.0651.0661.0681.070:一086洲1.0601.062:一:一:1.0521.0521.0531.0531.0541.0551.0561.0571.059:一1.0661.0671.0681.0691.0701.0711.0731.0751.0771.080:一:1.璐21.0851.0891.0921.0961.1001.1051.1091.1151.1201.1261.1321.1381.1451.1521,1601,1671,1761,184:一:;1,0841,0671,0701,0731,0761,0791,082
13、1,0861,0901,0951,0991,10_41.1101.0481,0481,0481,0491,0491,0501,0511,0531,0541,0561,0581,0611,0631,0661,0,701,0731,0771,0811,0851,0901,0951,1001,1051,1111,11773乃7678胡时85879094八OonnU盛IlnnU.抽.U.山n舀.扮RO九J自00甘0口0甘Q甘0公n甘nn叨内甘卜”0U01山IJ，山1.115l.121l.127l.134l.14ll.148l.1561,1101,1131,1181,1221,1261,1311,137
14、1,1421,1481,1551,161L,1681,1761,1841,1921,2001,2101,0971,0871.l011.1051.1101.1151.1201.125l.l311.137l.l441.150l.l58:一:1,1651,1731,1821,191:1,0611,0631,0651,0681,0711,0.741,0781,0811,0851,0901,0941,0991,1051,1101,1161,1221,1291,1361,1431,1511,1591,1671,1241,1311,1381,1461,1541,1621,0441,0441,0441,044
15、1,0451,0461,0471.0481.0501.0521.0541.0561.0591.0621.0651.06a1.0721.0761.0801.0851.0901.0951.1011.1061.1121.1191.1261.1331.1401.1481.157，孟nnlJ马0户口nlh抢JO公点0咭八乙人UOJ09的功101011垅1213”1415161717.，工，孟，山，主，人1互1，.孟1二且，土1二，1.之1通5678910111213141516171819幼21”23舰25舫2728幼3031脍洲润:45ii卜F1 519-82续表回潮温度飞率W、4.64.74.84.
16、95.05.15.25.35.45.55.6一一一万，.一.一，-二-一-升一-一一.一0030030030040040050081.0391.0391.0401.0401.0411.0421.0431.0441.0461.0481,.0501.0521.0551.0581.0611.0641.0681.0721.0761.0801.0851.0901,.0961.1公21.1081.1141.1211.1281.1351.1431.1521.0351.0351.036:一:一:1.0431.0461.0481.0511.0531.0561.0601.0641.0671.0721.0761.佣
17、11.0861.0911.0971.1031.1091.1161.1231.1301.1381.1471.0311.0311.0321.0321.0331.0341.0351.0361.0381.0391.0421.0441.0461.0491.0521.0561.0591.0631.0671.0721.0771.0811.0871.0931.0981.1051.1111.118L.1261.1341,1421,0281,0281,0281,0281,0291,0301,0311,0321,0341一351,0381,0401,0421,心451,0481,0521,0551,0591,063
18、1,0681,0721,0771,0831;0881,0941,1001,1071,1141,1211,1291,1371,0241,0241,0241,0241,0251,0261,0271,0281,0301“,0321,0341,0361,0391,0411,0441,0481,0511,0551,0591,0641,0681,0731,0781,0841,0901.0961,1031,1091,1171,1241.1321,020:一:1,0211,0211,0221,0231,0251,0261,0281,0301,0321,0351,0881,0411,0441,0盯1,0511,
19、0551,0161.0171,0妞1.0171,0181,0191,0201,0211,0231,0241,0261,0291,0311,0341,0371,0401,0441,0471.0511.0561.0601.0651.0701.0761.0821.0881.0941.1011.1081.1161.1231.0131.0131.0131.0141.0141.0151.0161.0181.0191.0211.0231.0251.0281.0301.0331.0361.040L.04心1.0481.0521.0561.0611.0661.0721.0781.0841.0901.0971.1
20、041.1111.1191.0101.0101.0101.0101.0111.0121,0131,0141,0161,0171,0191,0221,0241,0271,030一:一:1,0061.0061,0071,0071,0081,0081,0091.0111,0121,0141,0161,0181,0211,0231,0261,0291,0331,0371,0411,0451,0491,0541,0591,0641,0701,0761,0821.0891.0111,0131,0151,0171,0201,0231,0261.0291,0601,0641,0691,0741,0801.08
21、61.0921.0981.1051.1121.1201.0401.0441.0481.0531.0581.0631.0331.0371.0411.0461.0511.0561.0611.0671.0721.0791.0851.0921.1001.107肉匕n舀10甘n一1孟八”，二，止1.0681.0741.0801.0861.0931.1001.1071.1151l.lss5678910Jll213141516竹181920212223242526272829肋313233“35;n9FJ 519-826.56.66.7!一973973973974975娜978咖980982000000.9
22、780.9780,9780,9790.9790.9800.9吕10.9820,9840.9850,日合70.9890.9920.9940,9971.0001.0031.0071.0101.0141.0191.0231.0281.0331.0361.0441.0501.0561.0631.0701.0770,9760,9760,9760.9760.9770,9780.9790.9800.9810.9830.9750.9850.9870.9890.9920.9940.9981.0011.0041.0081.0121.0161.0201.0250.9850.9870.9890.9920.9950.9
23、981.0021.0301.0351.0411.0461.0531.0601.幼671.0741.0051.0091.0131.0181.0231.0281.0331.0391.0441.0511.0571.0641.071510FJ 519-82续表温度野6.86.97.07.17.27.37.47一57.67.77.80.9710.9710.9710.9720.9720.9730.9740.975D.977D.978:一:0.9670.9650.9650.9650.9650.9660.9670.9680.9690.9700.9720.9740.9760.9780.9810.9830.986
24、0.9890.9930.9961.0000.963:一:0.9580.9580.9580.9580.9590.9600.9610.9620.9630_9660.9540.9540.9540.9550.9560.9560.9570.9580.953!0.9670.9630.953公.9690.9700.9700.9710.9720.9730.9750.9760.9780.9800.9820.9850.9880.9910.9940.9971.0011.0050.9670.9680.9680.9690.9700.9710.9730.9740.9760.9780.9800.9830.9850.9880
25、.9920.9950.9991.0021,0061.口111.0161,0211,0261,0311,0371,0431,0501,0561.0630.9630.9530.9640.953:一:0,9610,9620,9620.963:一:一:)0,9690,9700.9720.9740,9760,9790,9810.9840,9870,9910.9940,9匀日1.0021,0071.0111,0161,0211,0271,0331,0391,0451,0521.059口.9640,9650,9660,9680,9700,9720.9740.977:一:0,9660.9680_9710.95
26、60.9570.9580.9600.9610.9631七呼了，孟58吕0.90甘甘OUOU.n”肉甘6“自U0.9800.9820.9840.9870.9900.9930,9960.9991.0031.0071.0111.0151.0201.0251.0300.9790,9820,9850,9890.9920.9960.9730.9760,9790,9820,9850.9890.9630,9650.9670.9700.9720.9750.9780.9820.9850.9890,9650,9680,9710.9730.9760.9801.0231,0361.0411,04公1,0541,0611
27、.0681.0091,0131,0181,0231,0281,0341,0391,0451,0521,0591.066:一:;1.0131,018047:一:1.0001,0051,0091,0141,0181,0241,0301,0361,0421,0491.0560,9590,9590,9590,9600,9600.9610.9620,9630,9650,9660.9680.9700.9720.9750.9780.9810.9840.9870.9910.9940.9981.0031.0071.0121.01了1.0231.0291.0351.0411.0471.0540.9壮0.9971.
28、0011.0051.0101.0151.0211.0261.0321.0391.0451.0520.9560.9560.9560.9570.9570.9580.959介.9600.9610.9630.9650.9670.9690.9710.9740.9770.9800.9830.9870.9910.9950.9991.0031.0081.0131.0191.0241.0301.0361.0431.0500.9930.9971.0021.0071.0121.0171.0231.0291.035:一:;1.的01.0051.0101.0151.0211.0271.0331.0391.0460甘翻，
29、二2品山马0八UnU567污91011121314巧161718192021韶邢别252e2728湘30书，创几dJ，rJ内J3n舀”J，d、11FJ619-82F1续表0.9520.9500.9490.9480.9460.9450.9420.9410.9410.9520.9500.9490.9480.9460.9450.9420.9410.9410.9520.9500.9490.9480.9460.9450.9420.9410.9410.9520.9510.9490.9480.9470.9460.9420.9420.9410.9530.9510.9530.9520.9500.9490.947
30、0.9460.9430.9420.9420.9510.9490.9480.94709440.9430.9420.9540.9580.952心.9500.9490.9480.9450.9440.9430.9550.9540.9530.9510.9500.9490.9460.9450.9440.9570.9550.9540.9540.9510.9500.9470.9460.9460.9580.9570.9560.9540.9530.9520.9490.9480.9470.9600.9590.9570.9560.9550.9540.9510.9500.9490.9620.9610.9590.9580
31、.9570.9560.9530.9520.951:0.9630.9610.9600.9590.9580.9650.9540.9530.8650.9640.9630.9610.9600.9570.9560.955:一:0.9680.9660.9650.9640.9630.9600.9590.9580.9710.9690.968:一:;0.9660.9440.9440.9440.9460.9450.9460.9470.9480.9490.9510.9530.9550.9570.9590.9620.9650.9680.9710.9740.9780.9920.9860.9910.9951.0001.0
32、051.0111.0171.0231.血91.0360.620.9610.9610.9750.9740.9720.9710.9690.9650.9640.9640.9780.9770.9760.9740.9720.9690.9680.9670.9820.9810.9790.9790.9750.9720.9710.9700.9860.9840.9830.9820.9790.9760.9750.9740.9900.9990.9870.9860.马启30.9800.9790.9780.9940.9930.9910.9900.9870.9840.9830.9820.9980.9970.9960.994
33、0.9920.980.9870.9871.0031.0021.0000.9990.9960.9930.9920.9911.0081.0071.0051.0040.9980.9970.991.0131.0121.0111.009:1.0031.0021.0011.0191.0181.0161.0151.0121.0091.0081.0071.0251.0241.0231.0211.0141.0131.0121.0311.0301.0281.027:;:1.0201.0191.0181.0371.0361.0351.0330.9730.9760.9800.98d0.9880.9930.9971.0
34、021.0081.0131.0191.0251.0311.038:一:)1:0271.0261.0251.0451.0431.0411.0401.0331.0321.03156759101112131415场171819幼幻韶23洲巧邓2728肠30盯32333435几卫2F1 819-82续表温IJ，二。.。，.，9.39.3，.，.。.。川，.。一，.。10.0哑度t、!0.9400.9390.9390.9380.9380.9370.9370.9360.9360.9360.9360.9400.9390.9390.9380.9380.9370.9370.9360.9360.9360.9360
35、.9400.9390.9390.9380.9380.9370.9370.9370.9360.9360.9360.9400.9390.9390.9380.9380.9380.9370.9370.9360.9360.9360.9410.9400.9400.9390.9390.9380.9380.9370.9370.9370.9370.942:一:;0.9400.9400.9390.9390.9380.9380.9380.9380.9380.9430.9410.9410.9400.9400.9390.9390.9390.9380.9380.9440.9430.9420.9420.9410.9410.
36、9400.9400.9400.9400.9400.9410.9420.9440.9460.9450.9440.9440.9430.9430.9420.9420.9410.9410.9410.9470.9460.9450.9440.9430.9440.9430.9430.9430.9420.9480.9470.9460.9460.9450.9450.9450.9440.9440.9500.9490.9480.9480.9470.9470.9470.9460.9460.9520.9510.9500.9500.9490.9490.9490.9480.9480.9480.9540.9530.9530.9520.9520.951:1.0151.022:1.0211.0201:0201.0311.0301.0291.0281.0271.0271.0261.0191.026:一:一:;:5678910n琦1314巧拓171819202122232425肠27朋29303132333435FJ 519-82附加说明:本标准由纺织工业部科技司提出，由上海市纺织工业局计量标准管理所、上海市棉纺织工业公司归口。本标准由北京市纺织工业局起草.本标准主要起草人阎秀梅、汪世爱等。
