1、A-A-5210 83 = 9999974 00b2205 3 a p - FI A-A-52108 June 28, 1991 CLDIFI, -, OCTrroN AND S-C, OR SY“ETIC Ihe General services Mtninistration has authorized the use of this ccamxical item desmiption in preferenoe to Military Specification MIM-43920. Abstract. synthetic cloth interded for use as.inter1
2、ining material. inteded for use as waictband interlining for mens tmusers. cloth is interded for use as a unidirectional stiffener in garrison an service cap. Ibis comnercial itan description avers cotton and synthetic or nie type I cloth is nie type II 1.1 Classification. (see 5.1). nie cloth shall
3、 be of the following types as specified Type I - 5.8 OZ. per sq. ya. Type II - 4.5 oz. per sq. ya. 2. CaLJEmrnCs 2.1 General descrirkion. Ihe warp yarns shall be either 100 percent carded or ccmhe sirqle ply catton, 100 percent polyester, any combination of polyester and catton, or frrmn 45 to 100 p
4、eroent polyester with the remining percentage rayon. Ihe fiiiirq yarns shall be 100 percent nylon or CO- polyester monofilament. me cloth shall be plain weave. %e width shall be as specified (see 5.1) and shall be the minimum acceptable width inclusive of the selvage when fly-shuttle loans or shuttl
5、eless locaiic with tuck-in selvages are used. between the last warp yam on each side excluding the protruding fringe(s). The color of the cloth shall be natural unless otherwise cpecified (see 5.1). 0 For all other shuttleless looms the width measurement shall be made Beneficial ocprmientc, recuamne
6、ndationc, additions, deletions, clarifications, etc., and any other data which may me this doc=ument should be sent to: cc;amMnder, U.S. Amy Natick distribution is unlimited. Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-52108 83 m 9999974 O062
7、206 5 m A-A-52108 2.2 plivsica recu rements. nie cloth shall confonn to the requhwmts listed in table i. characrterictic Weight, oz./sq.yd. (min) 5.8 4.5 Yamsper inch (min): warp 29 Filling 22 30 24 Stiffness inch-pcxd filling: o. 100 0.060 0.210 o. 101 shrinkage percent (max): warp 2.0 2.0 5041 505
8、0 5050 5202 5202 5552 I/ nie test methos indicated, fmn -191 Wile !est wthos, have been found acceptable to detedm if the cloth meets the stated requirements. stated -ts, the test mthos inicated shall be used. if the Guvenrment requirec proof that the cloth meetc the 2.3 Lienath and Dut-m. 2.3.1 Ful
9、l width. Unless otherwise specified (see 5.1), the cloth shall be furnished in conthous lengths of not less than 40 yards. nie cloth shall be -up full width on rolls as specified in 4.1. 2.3.2 Nm width. Unless otherwise specified (see 5.1), the cloth shall be furnished in lengths of 140 yards f 10 y
10、ards put-up on mlls as specified in 4.1. 3.1 certification. nie contractor shal certia, and maintain substantiating evidence that the pro to the pro&cers awn drawings, specifications, ctandards, and quality accurance practices. nie GaveMmient reserves the right to require proof of such confoxmance p
11、rior to first delivery and thereafter as may be otherwise pravided for uner the pravisions of the contract. 2 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-L- e A-A-52108 83 999997Y 0062207 7 A-A-52 108 p - 3.2 Visual examination. Lots of cloth sha
12、ll be in accort-lance with MIGSTD-105. (AQL), expmssed in terniC of defects per hunded units, shall be 4.0. The lot linear Yazd. Ihe cloth shall be examined for the folluwhq defects: hole, cut, tear, smash, lrnotc, missing en or pick, enkedded crease or wrinkle, clubs, si- or gout, spots or stains.
13、The inspection level shall be I and the acceptable quality level 3.3 hmth examination. sample shall be examined for length. my length found to be less than the minimum specified or more than 2 yards less than the length marked on the roil tickt shall be considewd a length defect. If two or mom rolls
14、 in the sample are defective with mspect to length or if the total of the actual lengths of rolls in the sample is less than the total of lengthc marked on the mll tickts, the lot shall be rejected. Wing the visual examination, each roll in the 3.4 ReuulatorvrecnUremen ts. The offemr/contractor is e
15、ncouraged to use recavered material in acconlance with Public Law 94-580 to maxirmrm extent practicable. 4. PACXXW 4.1.1 FUll-width cloth. spiral-wrnuia chiphazd tube. The tube shall have a 91100th finish surface that will pxwent the fibers of the diipboard fmn transferring to the cloth. ach roll of
16、 cloth, m-up as specified, shall be wram with 60-pound minimum bis weimt mft paper in such a way that the paper -1 emircle the mi1 at least once with a mhhmm overlap of 3 inches, and the width of the paper shall be sufficient to fold over and protect the erdc of the roll. Gummed paper tape, with a m
17、inimum width of 2-1/2 incha shall be applied to the Werlap seam the full length of the roll and across ch end. Alternately, each roll of cloth shall be encloced in a polyethylene film tube, secured at both ends by heat sealing or mechani cal ties. The cloth shall be rolled on a cornrolute or 4.1.2 N
18、arzraw-w idth cloth. Each roll of cloth shall be packaged in a clear plastic bag coriforming to A-A-1668. 4.2 packiml. 4-2.1 FUll-width cloth. tub- made fran woven polyprcpylene cloth. aie tube shall be cecured by heat-eing, by means of a mechani cal tie, or by plastic ties with a lock-end. Alternat
19、ely, a maximum of 325 pounds of rolls of hft-wrappd cloth el be pachi in a -fitting double-walled fberbaxd container kmwnasadoublecwer, andshalloonsistofabodyorjoi.nedinerandt mers (see figues 1 and 2). oornigated f- with a minirmmi burst- strength of 500 paunds shall be used. ?he container shall be
20、 stram with Each wram roll shall be enclosed in a bias-sewn 3 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-52108 83 E 999997L, O062208 9 A-A-52108 metallic straps not less than 1/2 by 0.020 inch or non-metallic strap not less than 7/16 by 0.03
21、0 inch. 4.2.2 Narrowwidth cloth. Cloth, packaged as specified, shall be stacked in a snug-fitting f- shirning container conforming to style %C, type CF variety SCJ or SF, class doSnestic, grade 275 of P.PF43-636. Each shipping container shall be closed in accordance with the appendix of PFP-B-636. T
22、he weight of the contents of each shipping container shall not 55 pounds. 4.3 palletization. mrmwwidth cloth. When specified (see 5.2), cloth packed as specified, shall be palletized in accorclance with load type la of MIGSTD-147. Each prepared load shall be bonded with primary and secondary straps
23、in accoiance with bonding means C arid D or film bonding means F or G. pallet pat- shall be in accordance with the appendix of MIGSTD-147. 4.4 Mar-. in addition to any special markings required by the contract or purchase order, roils and shipping containers shall be mark& in accordance with MIGSTD-
24、129. Each roll shall have a piece ticket (identification tag) affixed with a 5-ply minhum cotton string or a plastic tag hanger. shall have a reinforced eyelet arid shall be legibly printed, using water insoluble ink, with the folluwing information: Ihe tag -t w=Y National Stock Number tem &scriptio
25、n Rol1 Number Contractor Lot Number Width Piece Number Fiber Content Yardage Contract or Purchse order Ntmiber Fhkh or Gmige Mill 5. NcmEs 5.1 Acau isition recniiremen ts. Acquisition documents must specify the follming: a. Title, number, and date of this document. b. Type required (see 1.1). c. Wid
26、th of cloth required (see 2.1). d. Color required, if other than natural (see 2.1). e. Liength and put-up if other than specified (see 2.3). f. Palletization, if required for narmw-width cloth (see 4.3) . 5.2 Saurcec of documentC. 5.2.1 Saurce of Goverrmient documente. Copies of Military anti Federa
27、l dccumnts are available fm: standardization Dcxxmients order Desk Building 4D 700 Fbbbins Avenue Philadepaiia, PA 19111-5094 4 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-p. I- o a A-A-52108 3 9799974 0062207 O W MI- ItamEsm Amiy-a Navy-Nu Air F
28、o- - 11 &dew activities: Amiy-m Navy-Mc Ah? Fo- - 82, 99 DIA - CI A-A-52108 CIVIL AGENCY OooRDlWTNG ACXIWIY: GSA-FSS PREPARINGAClTWIY: (Project 8305-0381) 5 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-A-A-52108 83 9999974 O062230 7 A-A-52108 Figure 1. Oxers and joined her of double-wall mrrugated fiberbard wntainer. . Figure 2. Fbur rolls packed in a ib&le-wall corrugated fiberbard wntainer. * 6 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-
