1、AMSC N/A FSC 6140 DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited INCH-POUND MIL-PRF-32383/3 16 June, 2011 PERFORMANCE SPECIFICATION SHEET BATTERY, RECHARGEABLE, SEALED, BB-2590()/U, BB-390()/U, AND BB-3590()/U The requirements for acquiring the product herein shall
2、consist of this specification sheet and MIL-PRF-32383. FIGURE 1. FIGURE 2. BB-2590()/U and BB-3590()/U BB-390()/U FIGURE 1 minimum final voltage is 10V, minimum final voltage for BB-390()/U is 9V Copyright Communications - Electronics Command Provided by IHS under license with CRAINot for ResaleNo r
3、eproduction or networking permitted without license from IHS-,-,-MIL-PRF-32383/3 5 10. The discharge profile shall be no less than as follows. Motor inrush current (3.5.5) Step Start time End time Current (A) (minute:second:millisecond) 1 00:00:000 05:00:000 5 2 05:00:000 05:00:010 22.5 3 05:00:010
4、05:00:020 20 4 05:00:020 05:00:030 19 5 05:00:030 05:00:040 18 6 05:00:040 05:00:060 17 7 05:00:060 05:00:100 16 8 05:00:100 05:00:175 15 9 05:00:175 05:00:325 14 10 05:00:325 05:00:575 13 11 05:00:575 05:00:850 12 12 05:00:850 05:01:000 11 13 05:01:000 10:00:000 10 14 Repeat steps 1 through 13 15 2
5、0:00:010 Until cutoff voltage 5 11. For BB-2590()/U and BB-xx90/U batteries, the charge enable terminal shall comply with the following: Charge enable (3.5.4) a. Maximum charge without enable: 400 mA b. Equivalent resistor: 235 c. Equivalent diode VF: 1.3 V d. Approximate activation current: 7 mA 12
6、. High temperature temporary cut off devices (3.7.5)There shall be not less than four temporary cut off devices complying with 3.7.5. . 13. High temperature permanent cut off devices (3.7.6)For BB-390()/U batteries there shall be not less than two permanent cut off devices complying with 3.7.6. For
7、BB-2590()/U and BB-xx90/U batteries batteries there shall be not less than two permanent cut off devices complying with 3.7.6. . 14. Electromagnetic compatibility (3.8)N/A : 15. Constant potential, current limited (4.6.1)A constant potential of 16.5 volts shall be applied to each battery section ind
8、ependently with current limited to 3 amperes, to a charge cut off of 100 milliamperes. . Copyright Communications - Electronics Command Provided by IHS under license with CRAINot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-32383/3 6 16. Constant current (4.
9、6.2). a. Fast-charge each battery section independently at 4.3 0.3 amperes until either the battery reaches 16.5 volts or a negative voltage drop is detected; Constant current charging is divided into two stages as follows: b. Topping charge is in two parts: (1) continue charge at 480 5 milliamperes
10、 for not greater than 2 hours, then (2) charge at 230 5 milliamperes until the total charge capacity reaches 6.9 amp-hours. c. Rest periods during charge are permitted but not required, provided the total charge time is not more than 5 hours. 17. Alternate charging (4.6.3)a. BB-390()/U: . The follow
11、ing methods may be used whenever the general specification allows use of alternate charging: Charge fully discharged batteries in the 24-volt mode at 480 ma constant current for 12 hours. b. BB-2590()/U and BB-3590()/U: Charge each section independently with a constant potential of 16.5 volts and cu
12、rrent limit of 3 amperes max. 18. Capacity discharge (4.7.2.3)Discharge at 2A in series mode. . 19. Cycle life test (4.7.2.4)All cycles shall be at a 2A discharge rate. . 20. Pulse discharge (4.7.2.11). Discharge with the battery sections connected in parallel with 36 amperes for 5 seconds followed
13、by 25 seconds off load. 21. Overcharge/electric leakage (4.7.4.7). Charge in parallel mode at 4.0 amperes with a charge voltage limit of 40 volts during the 21-hour overcharge period of 4.7.4.7b. Discharge batteries at a constant 2A load to final voltage in step 4.7.4.7e. 22. Electromagnetic interfe
14、rence (4.7.7). N/A. VARIANCES: Each battery shall comply with MIL-PRF-32383 except as follows. A. State-of-charge display characteristics (3.5.7.2)Delete: Replace with: . For BB-390()/U batteries ONLY, modify as follows: SEGMENTS STATE OF CHARGE 0 = 0% (Fully Discharged) 0 = 0% (fully discharged) SE
15、GMENTS STATE OF CHARGE 1 = 1 to 20% 1 = 0 to 24% 2 = 21 to 40% 2 = 25 to 42% 3 = 41 to 60% 3 = 43 to 65% 4 = 61 to 80% 4 = 66 to 92% 5 = 81 to 100% 5 = 93 to 100% Copyright Communications - Electronics Command Provided by IHS under license with CRAINot for ResaleNo reproduction or networking permitt
16、ed without license from IHS-,-,-MIL-PRF-32383/3 7 ADDITIONAL FIGURES Note: Dimensions are in inches. Tolerance is 0.031 inches. FIGURE 3. BB-390 Copyright Communications - Electronics Command Provided by IHS under license with CRAINot for ResaleNo reproduction or networking permitted without license
17、 from IHS-,-,-MIL-PRF-32383/3 8 Note: Dimensions are in inches. Tolerance is 0.031 inches. FIGURE 4. BB-2590 and BB-3590 Copyright Communications - Electronics Command Provided by IHS under license with CRAINot for ResaleNo reproduction or networking permitted without license from IHS-,-,-MIL-PRF-32
18、383/3 9 NOTES: (This section contains information of a general nature which may be helpful, but is not mandatory) Nominal ratings: The following are the nominal ratings for the battery described by this specification sheet. They are provided for information purposes. Battery PIN: M32383/3 -2 -3 -4 T
19、ype Classification: BB-390()/U BB-2590()/U BB-3590()/U Chemistry: Ni-MH Li-Ion Li-Po Color: Green “Desert tan” “Earth Yellow” Weight (max): 4.2 lbs (1.9 kg) 3.2 lbs (1.5 kg) 4.2 lbs (1.9 kg) Voltage Range: 14-31 20-33 20-33 Nomina Voltage: 24 28.8 28.8 Nominal Capacity: 4.6 Ah 7.4 Ah 10 Ah Nominal E
20、nergy (new battery): 110 Wh 213 Wh 288 Wh Rated power output: 180 W 200 W 200 W Battery Life: 224 cycles, 3 years Continuous load rating: 10 A Pulse load rating: 36 A (5 SEC) Charge temperature range: -4 to 122F (-20 to 50C) Operating temperature range: -22 to 140F (-30 to 55C) Storage temperature r
21、ange: -4 to 122F (-20 to 50C) MAX abusive temperature: (non-operating): 199F (93C) Connector: SC-C-179495 Overall Dimensions: 5 in. x 2.5 in. x 4.4 in. Non-rechargeable equivilent / Specification: BA-5590()/U and BA-5390()/U / MIL-PRF-32271/1 Note 1: BB-390()/U requirements were structured around lo
22、w self discharge cells Note 2: BB-2590()/U requirements were structured around 2.6Ah 18650 cells. Other dataNavy safety tests of NAVSEA S9310-AQ-SAF-010 are required for the BB-2590()/U and the BB-3590()/U batteries during first article testing. The test data provided from the testing will be used t
23、o evaluate applications for specific using devices and Navy platforms. Devices using this battery will require US Navy Safety Approval prior to use by Department of Navy users unless such approval has already been granted. Please consult with NAVSEA Instruction 9310.1 for further information. : Cust
24、odians: Preparing activity: Army CR Army CR Navy MC (Project Number 6140-2010-012) Air Force 99 Review activities: Navy AS, SH Air Force 71 DLA CC NOTE: The activities listed above were interested in this document as of the date of this document. Since organizations and responsibilities can change,
25、you should verify the currency of the information above using the ASSIST Online database at https:/assist.daps.dla.mil or https:/assist.daps.dla.mil/quicksearch/. Copyright Communications - Electronics Command Provided by IHS under license with CRAINot for ResaleNo reproduction or networking permitted without license from IHS-,-,-
