1、 UNIT LOAD DATA MIL-STD-1386-55 MI I LITARY STAN DAR D LORDING OF w,zARoous MATERIALS AND ASSBClATED ITEMS IN MlLVAN CONTAINERS CARTRIDGE, 76 MRt/62 CALIBER OR CHARGE, CLEARIN6 76 MM162 CALIBER FLEE; ISSUE LilulTI LOAD UNIT LOAD DRAWING . WR-54/263. WEIGHT OF UNIT LOAD CARTRIDGE (APPROX) . 1511 ins
2、 CLEARING CHARGE (APFROX). . 950 LBS DMNSIONS 48 3/4 L . 42 l/ W . 40 1/8 H CUM . 447cuFT DOT HAZARD CLASSIFICATION . SEE TABLE I COAST GUARD CUSS . SEE TADLE I INDX - ITEM - GENERAL NOTES IOFC/COFC, SHIP 6 HIGWAY (NAVY) 24 FEBRUARY 1975 2 2 63 NOlESi I. 2. UNLESS OTHERWISE SPECIFIED DIMENSIONS ARE
3、IN INCHES. FOR CROSS REFERENCE TO ASSOCIATED PALLETIZING, TRUCKLOADIRG AND CARLOADING MILITARY STANDARDS, REFER TO THE INDEX TO STANDARDS, MIL-HMK-236 (NAVY). I FSC 0140 APPROVED BY . :* I *u, .I . / . AUTHORIZED FOR TRAILER-ON- APPROVED PLY FLAT-CAR (TOFC), CONTAINER-BN- us COAST GUARD BUREAU OF EX
4、PLOSIVES FLAT-CAR (COFC), CONTAINERSHIP AND HIGHWAY SHIPMENTS - /. , ,;fi!:/i * . /p -c- ,- ” . .t= /I.% DAtE /2 ?,?. I n DATE - h)cp SK;NARE RECIION AGENT VOA) DATE NAVAL WEAPONS HANDLING LABORATORY DATE N A D EARLE, NEW JERSEY. PAGE 1 OF 3 mvKASY%OMBY DIRECTION Provided by IHSNot for ResaleNo repr
5、oduction or networking permitted without license from IHS-,-,-MIL-STD-1386-55 (NAVY) GENERAL NOTES I. THIS WCUMENT GIVES DETAILED INSTRUCTIONS FOP. LOADING THE MILVAN CONTAINER WITH FLEET ISSUE UNIT LOADS OF 76 hWf62 CALIBER CARIRIDG3 OR CLEARING CH4RGES. TM UNIT L04D SHALL BE PAI.LETIZED IN f XORDA
6、NCE WITH WR-54/263. THE MILVAN SHALL BE EQUIPPED WITH A MECHANICAL LOAD-BR4C:NG SYSTEM THA7 MEETS THE REQUIREMENTS OF TM BUREAU OF EXPLOSIMS PAMPHLET 6C. IN AODITION TO TE BELT PAILS FZQUIRED BY PAMPHLET 6C, THE MILVAN C3NTAINER HAS BELT RAILS AT THE i? AND 83 INCH HEIGHTS FROM TM CONTAINER FLOOR. 2
7、 3. WHEN POSITIONING CROSSMEMBERS, MAKE A VITUAL CHECK TO ENSURE THAI THE CROSSMEMBERS ARE LOCKED SECURELY IN PLACE. 4. CONTAINERS ARE EQUIPPED WITH 25 CROSSMEMBERS. UNUSED CROSSMEMERS WST REMAIN WITH THE CONTAINER AND SHALL BE FASTENED INTO BELT FAILS FOR SHIPMENT. 5. WHEN THE VOID BETWEEN THE CRO
8、SSMEMBER AND THE UN!T LOAD IS GREATER TMAN ONE INCH, USE FILL MATERIAL TO SHIM 6. APPLICALE MATERIAL SPECIFICATIONS: BEWEEN CROSSMEMBER AND UNIT LOAD AS SHOWN IN DETAIL A. WNNAGI: LUMBER - FED. SPEC. MMi-751 NAILS -FED. SEC. FF-N-la, WPE U, SME 1C. COMMON BRIGHT. 7. AFTER BLOCKING AND BRACING HAS BE
9、EN INSPECTED, ATTACK SHIPPING DOCUMENTS INSIDE THE CONTAINER IN AN ACCESSIBLE AREA, CLOSE AND SEAL CONTAINER DOORS AND ATTACH APRICABLE PLACARDS TO THE OUTSIDE OF THE CONTAINER FOR THE APPROPRIATE MODE OF TRANSPORTATION As PRESCRIBED IN OP 2165 (VOL. 1). TOFC/COFC,CONTAINERS#IP AND HIGHWAY 1. THE CO
10、NTAINER LOAD CONSISTS OF 16 UNIT LOADS WHICH MUST BE LOADED AND DUNNAGED IN ACCORDANCE WITH THIS DOCUMENT. 2. THE LOADED MILVAN CONTAINER SHALL BE ON A 2 FT MILVAN CHASSIS EQUIPPED WITH DOUBLE BOGIES WHEN BEING MOVED IN TOFC SERVICE. WHEN THE LOADED CONTAINER IS 1N TOFC OR COFC SERVICE, IT SHALL BE
11、ON FLAT RAILCARS THAT COMPLY WITH BUREAU OF EXPLO- SIVES PAMPHLET K. 3. 4. THE LOADED MILVAN MAY BE MOMD OVER Pvaiic HIGWAYS ON A MILVAN CHASSIS EQUIPPED WITH DOUBLE BOGIES OR ON SUITABLE COMMERCIAL EQUIPMENT OF APPROPRIATE CAPACITY. IN CERTAIN STATES THE GROSS MHICLE WEIGHT (G.V.W.) IS LIMITED BY T
12、HE DISTANCE BETWEEN THE AXLES OF THE ASSEMBLED RIG. CARE SHOULD E TAKEN TO SEE THAT THE PROPOSED G.V.W. DOES NOT EXCEED THESE LIMITATIONS. FILL MATERIAL 1 x 40Rix SXW INCMS LONG CROSSMEMBER 16 GA TIE WIRE ONE LOOP, TWIST TIED DETAIL FILL MAlERIAL SEE GENERAL NTE 5 Provided by IHSNot for ResaleNo rep
13、roduction or networking permitted without license from IHS-,-,-MIL-STD-138b -55 82 999991L 0072789 b I MIL-STD-1386-55 (NAVY) J SECTION B-6 CONTAINER LOAD DATA NUMBER OF UNIT LOADS . 16 NUMBER OF CROSSMEMERS REQUIRED. . 18 LOAD WEIGHT (APPROX) CARTRIDGE 24,176 LBS CLEARING CHARGE . 15.m LES CONTAINER WEIGHT 5,785 LBS GROSS WEIGHT (APPROX) CARTRIDGE . 29,961 LBS CLEARING CHARGE 5,785 LBS REVIEW ACTIVITY: NAVY -OS PREPARING ACTIVITY: NAVY -0s (PROJECT NO. 814-NZ72) PAGE 3 Provided by IHSNot for ResaleNo reproduction or networking permitted without license from IHS-,-,-
